Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Research on boiling heat transfer of aqueous extracts vacuum drying based on fractal theory

Modeling Simultaneous Heat and Mass Transfer for Microwave Drying on Apple

Microwave Vacuum Drying Properties and Kinetics Model of Radix Paeoniae Rubra Extract

Droplet Evaporation to Boiling in Van Der Waals Fluid

Modeling of Muti-layer Far-Infrared Dryer

Thermodynamic Analysis of a Freeze-Dryer Utilizing Hygroscopic Solution

Vapour-liquid rebalancing behaviour of free water evaporation kinetics: experimental investigation and modelling

[Application of microwave vacuum drying with process management in extract drying of personalized traditional Chinese medicine preparations]

Quality Evaluation and Heat and Mass Transfer Mechanism of Microwave Vacuum Drying of Astragalus Roots

Modelling the primary drying stage of the spray freeze drying process based on the non-equilibrium formulation

Drying characteristics, kinetics model and effective moisture diffusivity of vacuum far-infrared dried Rehmanniae

Fractal Pore Network Simulation on the Drying of Porous Media

Improved Techniques for Drying TCM Extracts

Theoretical and experimental research on heat and mass transfer in a turbine thin layer dryer

A heat transfer model for liquid film boiling on micro-structured surfaces

Multiphase porous media model with thermo-hydro and mechanical bidirectional coupling for food convective drying

Modeling moisture and heat transfer during superheated steam wood drying considering potential evaporation interface migration

Droplet boiling on heated surfaces with various wettabilities

Study on the response law between cooling rate and temperature with process parameters during vacuum freezing of liquid

Ultrathin liquid film phase change heat transfer on fractal wettability surfaces

Heat and mass transfer in vacuum drying process of fructooligosaccharides syrup