Abstract:Water concentration inside proton exchange membrane fuel cells (PEMFCs) is a key factor affecting performance and durability. Therefore, many studies have been conducted to maintain an appropriate moisture balance inside the stack. The most recent study was a study that confirmed moisture distribution using five sensors inside the anode and cathode. However, in this study, it is difficult to determine the exact moisture distribution inside the stack due to insufficient sensors. In this study, a unit cell PEMFC including micro relative humidity and temperature (RH/T) sensors with an active area of 100cm 2 was fabricated to characterize the water concentration. Before installing the micro sensors into the bipolar plates, a reliability test is conducted, and the result shows that the sensor is reliable at 60 °C and 70 °C. After that, for the in-situ temperature and relative humidity measurement, the 50 sensors are installed along the anode and cathode gas channels evenly in the active area. This study investigates the distribution of water transport behavior, temperature, and water concentration at 0.6 V, 0.5 V and 0.4 V of electric load. Dew point is introduced to analyze water concentration, and net water mole flux is calculated to evaluate water transport behavior. The results show that as the load applied to the PEMFC increases, higher temperature band expands from downstream to upstream of the gas flow. In addition, at 0.4 V, observing the highest temperature band between 61 °C to 62 °C, it is concluded that the flow field of the reaction zone is more activated along the downstream. Meanwhile, the anode becomes more dehydrated with higher load and the cathode more hydrated. At 0.4 V, the maximum dew point on the cathode is 37.5 °C, and the minimum dew point on the anode is 30 °C. In conclusion, even though water transports from the cathode to the anode, due to dry inlet gas, 20% of relative humidity, and high flow rate, hydrogen by 2.8lpm and air by 6.65lpm, the anode doesn't become hydrated.

Thermal neutron radiography of a passive proton exchange membrane fuel cell for portable hydrogen energy systems

Influence of Heat Transfer on Gas and Water Transport in Fuel Cells

Enhanced Understanding of Electrothermal Dynamics Kinetic Behavior for Commercial-Size PEM Fuel Cells Based on Impedance and Distributed Temperature Measurement

Proton exchange membrane fuel cell degradation under close to open-circuit conditions

Numerical Analysis of Static and Dynamic Heat Transfer Behaviors Inside Proton Exchange Membrane Fuel Cell

Development of Integrated Thermally Autonomous Reformed Methanol-Proton Exchange Membrane Fuel Cell System

Degradation Differences of a Single Proton Exchange Membrane Fuel Cell: Energy Management Strategy and Dynamic Programming

Modeling Water and Thermal Transients Inside Proton Exchange Membrane for Vehicle Application Fuel Cells

Research Progress of Heat Transfer Inside Proton Exchange Membrane Fuel Cells

Experimental Study of Proton Exchange Membrane Fuel Cells Using Nafion 212 and Nafion 211 for Portable Application at Ambient Pressure and Temperature Conditions

Portable Proton Exchange Membrane Fuel Cell Using Polyoxometalates As Multi-Functional Hydrogen Carrier

Multiple in-situ measurement of water transport in the bipolar plate of proton exchange membrane fuel cell

Water Distribution and Performance Variation in a Transparent PEMFC with Large Active Area

Dynamic accelerated stress test and coupled on-line analysis program to elucidate aging processes in proton exchange membrane fuel cells

Current density and temperature distribution measurement and homogeneity analysis for a large-area proton exchange membrane fuel cell

In situ investigation of heat and water distributions in the PEM fuel cell

In Situ Analysis of Performance Degradation of A Pemfc under Nonsaturated Humidification

Progress of air-breathing proton exchange membrane fuel cell

Proton exchange membrane fuel cell degradation under close to open-circuit conditionsPart I: In situ diagnosis

More Sustainable Electricity Generation in Hot and Dry Fuel Cells with a Novel Hybrid Membrane of Nafion/nano-silica/hydroxyl Ionic Liquid

Disclosure of the Internal Transport Phenomena in an Air-Cooled Proton Exchange Membrane Fuel Cell-Part I: Model Development and Base Case Study