Abstract:To address the trajectory tracking issue of upper-limb rehabilitation exoskeleton with uncertainties and external disturbances, this paper proposes a fractional-order ultra-local model -based model-free finite-time robust controller (FO-FTRC) using predefined performance sliding surface. Different from previous model-free control strategies, a novel multi-input multi-output (MIMO) fractional-order ultra-local model which is a virtual model is proposed to approximate the complex uncertain nonlinear exoskeleton dynamics in a short sliding time window. This allows the design of controller to be independent of any exoskeleton model information and reduces the difficulty of controller design. The developed robust model-free control method incorporates a fractional-order quasi-time delay estimator (FO-QTDE), unknown disturbance estimator (UDE) as well as prescribed performance sliding mode control (PPSMC). The FO-QTDE is utilized to estimate the unknown lumped uncertainties which employs short time delayed knowledge only about the control input. However, the low-pass filter is always added for FO-QTDE when disturbances change fast, which leads to unavoidable estimation error. Then, UDE is designed to further eliminate the estimation error of FO-QTDE to enhance control performance. The PPSMC is constructed to converge sliding surface to zero in a finite time. Besides, the sliding surface is always limited in performance boundaries. After that, the overall system stability and convergence analyses are demonstrated by using the Lyapunov theorem. Finally, with the comparison to other methods of α -variable adaptive model free control ( α -AMFC), time-delay estimation-based continuous nonsingular fast terminal sliding mode controller (TDE-CNFTSMC), time delay estimation (TDE)-based model-free fractional-order nonsingular fast terminal sliding mode control (MFF-TSM) and fractional-order proportion-differential (PD β ), the co-simulation results on 7-degree-of-freedom (DOF) iReHave upper-limb exoskeleton virtual prototype and experiment results on 2-DOF upper-limb exoskeleton are obtained to illustrate the effectiveness and superiority of the proposed FO-FTRC method.

A Robust Fuzzy Fractional Order PID Design Based On Multi-Objective Optimization For Rehabilitation Device Control

Design Fractional-order PID Controllers for Single-Joint Robot Arm Model

Fuzzy Logic Based Pid Control Of A 3 Dof Lower Limb Rehabilitation Robot

Adaptive Fractional-Order Super-Twisting Sliding Mode Controller for Lower Limb Rehabilitation Exoskeleton in Constraint Circumstances Based on the Grey Wolf Optimization Algorithm

Pole placement tuning of proportional integral derivative feedback controller for knee extension model

Model-free finite-time robust control using fractional-order ultra-local model and prescribed performance sliding surface for upper-limb rehabilitation exoskeleton

An Optimized Stimulation Control System for Upper Limb Exoskeleton Robot-Assisted Rehabilitation Using a Fuzzy Logic-Based Pain Detection Approach

Fractional-Order Ultra-Local Model-Based Optimal Model-Free Control for 7-DOF Irehave Upper-Limb Exoskeleton

Research on Fractional Order Fuzzy PID Control of the Pneumatic-hydraulic Upper Limb Rehabilitation Training System Based on PSO

Adaptive Fractional PID Controller for Robot Manipulator

Hybrid controller with neural network PID/FOPID operations for two-link rigid robot manipulator based on the zebra optimization algorithm

Optimal Fuzzy-FOPID, Fuzzy-PID Control Schemes for Trajectory Tracking of 3DOF Robot Manipulator

PD-Based Fuzzy Sliding Mode Control of a Wheelchair Exoskeleton Robot

A PID-Controlled Approach in the Design of a Physiotherapy Robot for Upper Arm Rehabilitation

Adaptive-Robust Controller for Smart Exoskeleton Robot

Fractional-order self-tuned fuzzy PID controller for three-link robotic manipulator system

FRACTIONAL ORDER BASED COMPUTED TORQUE CONTROL OF 2-LINK ROBOTIC ARM

Multi-objective LQR with Optimum Weight Selection to Design FOPID Controllers for Delayed Fractional Order Processes

Robustness and Tracking Performance Evaluation of PID Motion Control of 7 DoF Anthropomorphic Exoskeleton Robot Assisted Upper Limb Rehabilitation

Fractional-Order [proportional Derivative] Controller for Robust Motion Control: Tuning Procedure and Validation

Fuzzy Sliding Mode Control of a Multi-DOF Parallel Robot in Rehabilitation Environment