Abstract:The stereo-vision methods have been developed and used for measuring the wing deformation while the aircraft is in flight. However, it is difficult to achieve accurate measurement in flight test since inevitable camera movements often occur due to elasticity in the camera support and the surrounding structure, especially during heavy turbulence and large maneuver flight. Any slight camera movements within a stereo-vision system can directly influence the calibrated extrinsic parameters, then decrease 3D reconstruction accuracy, and even cause the measurement to fail. This study proposes a method to correct the effect of the camera movements to enable accurate wing deformation measurement using a stereo-vision system. A reference coordinate system is established based on the control points to unify the changing camera coordinate system. A dynamic extrinsic parameters calibration algorithm is developed to estimate the instantaneous position and orientation of the stereo cameras. To verify the presented method, an experiment in which the stereo cameras occurring relative movement was performed. The results show that the proposed method has effectively corrected the effects of camera movements. Furthermore, the proposed method was applied to the practical wing deformation measurement of a UAV in fieldwork. The maximum error of length and displacement is less than 0.8 mm when the stereo cameras remained unchanged. The actual accuracy of the overall measurement system is about 0.01% of the observed area (e.g. 0.8 mm in 6 m scale) under the conditions of flat viewing angle and outdoor scenes. While camera movements occur during the test, the corrected RMS error of displacement is reduced to about 1.5 mm and has decreased by 50% compared with that before correction. The enhanced precision and robustness of wing deformation measurement are well realized by the proposed method of correcting camera movements.

A New Baseline Measurement Method for Multinode and Multibaseline Interferometric SAR Systems Using Fiber Bragg Gratings

A Flexible Baseline Measuring System Based on Optics for Airborne DPOS

A Novel Method to Simultaneously Measure the Straightness

A Novel Method To Enhance The Sensitivity For Two-Degrees-Of-Freedom Straightness Measurement

A modeling and calibrating method of FBG sensors for wing deformation displacement measurement

Local structural health monitoring system in aircraft based on fiber Bragg grating array

Fiber Bragg Gratings Sensors for Aircraft Wing Shape Measurement: Recent Applications and Technical Analysis

Dynamic Deformation Measurement of Bionic Flapping-Wing Robot Based on Fiber Bragg Grating Array

Effective Optical Fiber Sensing Method for Stiffened Aircraft Structure in Nonlocal Displacement Framework

An Online Measurement and Calibration Method for a Radio Telescope Sub-Reflector Support Structure Using Fiber Bragg Grating

A Three-Dimensional Deformation Monitoring Method: Combining Optical Deformation Monitoring Based on Regression Models and GB-SAR Interferometry

Wing deformation measurement using the stereo-vision methods in the presence of camera movements

Novel Measurement Method for Full-field Bridge Strain and Displacement with Limited Long-gauge Strain Sensors

In-flight health monitoring of a subscale wing using a fiber Bragg grating sensor system

A Novel Method for Airborne SAR Tomography Baseline Error Correction Driven by Small Baseline Interferometric Phase

Conceptual Study and Performance Analysis of Tandem Multi-Antenna Spaceborne SAR Interferometry

An Advanced Interferometric Baseline Estimation Method (IBEM) for Spaceborne Bistatic SAR

System Concepts and Potential Applications of a Tri-Beam Spaceborne SAR Mission

Measurement Refinements of Ground-Based Radar Interferometry in Bridge Load Test Monitoring: Comprehensive Analysis on a Multi-Span Cable-Stayed Bridge

Discontinuous Deformation Monitoring of Smart Aerospace Structures Based on Hybrid Reconstruction Strategy and Fiber Bragg Grating

Improve Multi-Baseline InSAR Parameter Retrieval by Semantic Information from Optical Images.