Abstract:Thermochemical water splitting (TCWS) is an attractive and promising approach for hydrogen fuel production to replace fossil fuels and address climate change. The novel approach used in this study is the indirect irradiation of the ceria particle with solar-heated nitrogen in a fluidized bed reactor which improved the ceria thermo-reduction and increased hydrogen yield. The TCWS plant featured additional units for oxygen co-production, and excess heat recovery to generate electricity and reduce the saleable hydrogen price. Two fluidized bed reactors for ceria thermo-reduction and oxidation using steam were modelled in Aspen Plus for hydrogen production at a 70% capacity factor. A photovoltaic (PV)-battery module in addition to the solar parabolic dish collector (PDC) was then used to deliver operation-round electricity supply and drive mechanical and control systems, reducing overall plant energy cost. Three minimum selling prices of hydrogen were considered based on the achievable products of the TCWS plant: (i) pricing based on no co-products, (ii) pricing including oxygen revenue, and (iii) pricing including oxygen and electricity revenue. The TCWS plant achieved a minimum selling price (MSP) of 3.92 USD/kg H2 (including oxygen and electricity revenue) at a 10% discount rate which is the lowest for solar-driven TCWS hydrogen compared with other similar studies. Sensitivity analyses showed that discount rate, steam Rankine cycle, power block, cost of ceria and hydrogen storage, and price of oxygen, respectively, had the highest impact on the MSP of the TCWS hydrogen plant. The switch value analysis (SVA) was used to determine the potential of achieving the global target hydrogen price of 2 USD/kg based on a single parameter assessment. The TCWS plant proposed in this work provides a promising approach toward achieving future hydrogen prices below 2 USD/kg when a lower discount rate of 5% is utilised. It was established that the choice and size of concentrated solar power (CSP) technology integration, co-generation, and heat recovery are critical to the system efficiency and economic viability of a solar-driven TCWS hydrogen production. This work demonstrated the use of ceria as a metal oxide feed suitable for solar TCWS hydrogen production with a promising economic potential for a global target price of less than 2 USD/kg H2 based on the choice of process-CSP configuration.

Thermodynamic analysis on CSP integrated cerium oxide (CeO2 − CeO1.72/1.83) water splitting cycle for hydrogen production

Extraction of Hydrogen from Water Using CeO2 in a Solar Reactor Using a Concentrated Flux of Solar Radiation

Coupling the full solar spectrum with a two-step thermo-electrolytic cycle for efficient solar hydrogen production

Thermochemical Properties of High Entropy Oxides Used as Redox-Active Materials in Two-Step Solar Fuel Production Cycles

Solar-driven H2O/CO2 conversion to fuels via two-step electro-thermochemical cycle in a solid oxide electrochemical cell

Thermodynamic assessment of nonstoichiometric oxides for solar thermochemical fuel production

The water splitting cycle for hydrogen production at photo-induced oxygen vacancies using solar energy: experiments and DFT calculation on pure and metal-doped CeO2

Assessing the Viability of GeO2/GeO Redox Thermochemical Cycle for Converting CO2 into Solar Fuels

Techno-economic evaluation of solar-driven ceria thermochemical water-splitting for hydrogen production in a fluidized bed reactor

Thermodynamic Analysis of a Conceptual Fixed-Bed Solar Thermochemical Cavity Receiver–Reactor Array for Water Splitting Via Ceria Redox Cycling

Platinum Group Metal Catalyst (RuO x , PtO x , and IrO x )-Decorated Ceria-Zirconia Solid Solution as High Active Oxygen Carriers for Solar Thermochemical CO 2 Splitting

Thermodynamic and First-principles Assessments of Materials for Solar-driven CO2 Splitting Using Two-step Thermochemical Cycles

Boosted Solar Thermochemical Low‐temperature CO2 Splitting On Pt/CeO2 By Interface Catalysis

Enhanced Solar-to-Fuel Efficiency of Ceria-Based Thermochemical Cycles via Integrated Electrochemical Oxygen Pumping

Redox Kinetics and Nonstoichiometry of Ce0.5zr0.5o2-Delta for Water Splitting and Hydrogen Production

Thermodynamic analysis of titanium dioxide-based isothermal methanothermal and carbothermal redox cycles for solar fuel production

A novel exergy analysis method for cerium-based solar thermochemical cycles

Boosting Solar Photothermal Synergy for Efficient Overall Water Splitting Based on Mg, Al Codoped and Rh/Cr2O3/CoOOH Coloaded SrTiO3

Metal oxide composites and structures for ultra-high temperature solar thermochemical cycles

Sensitivity analysis and optimization of geometric and operational parameters in a thermochemical heat storage redox reactor used for concentrated solar power plants

Thermal and electrochemical performance analysis of an integrated solar SOEC reactor for hydrogen production