Enhancing sustainability in concrete: synergistic effects of sugarcane bagasse ash and iron ore tailings as eco-friendly cement and sand replacements

Yelisetty Murali Krishna,P. R. Dhevasenaa,G. Srinivasan,Ch. Naga Satish kumar
DOI: https://doi.org/10.1007/s41024-023-00369-0
2023-12-22
Journal of Building Pathology and Rehabilitation
Abstract:The construction industry is affected due to a shortage of river sand, besides, the production of cement releases large amounts of CO2 into the atmosphere which leads to global warming. There is an imperative to identify viable replacements for river sand and cement. Various industrial by-products have been used in earlier studies as sand and cement replacements which give a better performance of concrete. This study is mainly focused on the substitution of Iron ore tailings (IOTs) as a partial replacement of sand and sugarcane bagasse ash as a partial replacement of cement. After the mineral processing of Iron ore, the waste is generated, which arise many environmental issues for both living and nonliving components. Similarly, after squeezing the juice from sugarcane a waste is generated known as bagasse. The bagasse is used as a fuel in a cogeneration boiler to produce electricity. The leftover ash created in this procedure is known as bagasse ash. Concrete made from IOTs and sugarcane bagasse ash is tested and their results are analyzed. The concrete mix is designed for M30 with a water-to-cement ratio (W/C) of 0.48. A total of 13 mixes are developed by replacing 0%, 10%, 20%, 30%, 40% and 50% of IOTs with sand, 0%, 5%, 10%, 15%, 20% and 25% with processed sugarcane bagasse ash (SBA) and a mix containing both IOTs and SBA. The workability, compressive strength and Ultrasonic Pulse Velocity (UPV)) tests are conducted for all the mixes. The split tensile strength, flexural strength, sorptivity and acid resistance were done for the mix to obtain optimum compression strength. The test results show that workability falls off with the increment of IOTs as well as in the increment of SBA in percentage. The same pattern is also observed in the combination of IOTs and SBA. Compression strength values up to 30I and 20A replacement is above the target mean strength. The optimum compression strength is achieved for the mix containing 10 T and 10A. The compression strength for 10A10I also shows good results when compared to controlled concrete. A similar trend is also observed in all the tests.
What problem does this paper attempt to address?