Abstract:Integrated wastewater treatment processes are accepted as the best option for sustainable and unrestricted onsite water reuse. In this study, moving bed biofilm reactor (MBBR), membrane bioreactor (MBR), and direct contact membrane distillation (DCMD) treatment steps were integrated successively to obtain the combined advantages of these processes for industrial wastewater treatment. The MBBR step acts as the first step in the biological treatment and also mitigates foulant load on the MBR. Similarly, MBR acts as the second step in the biological treatment and serves as a pretreatment prior to the DCMD step. The latter acts as a final treatment to produce high-quality water. A laboratory scale integrated MBBR/MBR/DCMD experimental system was used for assessing the treatment efficiency of primary treated (PTIWW) and secondary treated (STIWW) industrial wastewater in terms of permeate water flux, effluent quality, and membrane fouling. The removal efficiency of total dissolved solids (TDS) and effluent permeate flux of the three-step process (MBBR/MBR/DCMD) were better than the two-step (MBR/DCMD) process. In the three-step process, the average removal efficiency of TDS was 99.85% and 98.16% when treating STIWW and PTIWW, respectively. While in the case of the two-step process, the average removal efficiency of TDS was 93.83% when treating STIWW. Similar trends were observed for effluent permeate flux values which were found, in the case of the three-step process, 62.6% higher than the two-step process, when treating STIWW in both cases. Moreover, the comparison of the quality of the effluents obtained with the analysed configurations with that obtained by Jeddah Industrial Wastewater Treatment Plant proved the higher performance of the proposed membrane processes.

Performance of Compact Bio-Contact Oxidation Reactors for Municipal Wastewater Treatment Under Different Hydraulic Retention Time

Effect of the Rapid Increase of Salinity on Anoxic-Oxic Biofilm Reactor for Treatment of High-Salt and High-Ammonia-nitrogen Wastewater.

Oxidation Ditches for Recycling and Reusing Wastewater Are Critical for Long-Term Sustainability—A Case Study

Performance of anammox UASB reactor treating low strength wastewater under moderate and low temperatures

Short-Cut Nitrification of Iraqi Municipal Wastewater for Nitrogen Removal in a Single Reactor

Review of Upflow Anaerobic Sludge Blanket Reactor Technology: Effect of Different Parameters and Developments for Domestic Wastewater Treatment

Performance of a hybrid anaerobic-contact oxidation biofilm baffled reactor for the treatment of decentralized molasses wastewater

Biotreatment of AL-KARAMA Teaching Hospital Wastewater Using Aerobic Packed Bed

Domestic wastewater treatment using an anaerobic bioreactor coupled with membrane filtration

Development, performance and microbial community analysis of a continuous-flow microalgal-bacterial biofilm photoreactor for municipal wastewater treatment

Performance of an Integrated Reactor with Airlift Loop and Sedimentation for Municipal Wastewater Treatment: A 150 M3/d Pilot Case Study

A Pilot Plant Study Using A Contact Oxidation Filtration Separation Integrated Bioreactor to Treat Municipal Wastewater

Biotreatment of Sulfate-Rich Wastewater in an Anaerobic/Micro-Aerobic Bioreactor System

Evaluation of a Hybrid Moving Bed Biofilm Membrane Bioreactor and a Direct Contact Membrane Distillation System for Purification of Industrial Wastewater

Micro-Polluted Water Treatment by Biological Contact Oxidation Process: Aeration Mode and Bacteria Community Analysis

Domestic Wastewater Treatment Using A Submerged Membrane Bioreactor

Municipal wastewater treatment by an anaerobic hybrid reactor at ambient temperatures

Performance of micro-pressure double-cycle coupled membrane integrated bioreactor for the treatment of urban sewage

Characteristics of oxygen mass transfer and its impact on pollutant removal performance and microbial community structure in an aerobic fluidized bed biofilm reactor for treatment of municipal wastewater

Residence time distribution experiments in a hybrid anaerobic blanket reactor treating real pharmaceutical wastewater

Influence of Hydraulic Retention Time (HRT) upon the Treatment of Wastewater by a Laboratory-Scale Membrane Bioreactor (MBR)