Abstract:Dry Anaerobic Digestion (AD) presents different advantages if compared to wet AD, i.e. smaller reactor size, lesser water addition, digestate production and pretreatment needed, although several studies have demonstrated that water promotes substrate hydrolysis and enables the transfer of process intermediates and nutrients to bacterial sites. To better understand the role of water on AD, dry and semidry digestion tests of selected complex organic substrates (food waste, rice straw, carrot waste), with various TS contents of the treated biomass have been carried out in the present study. The results confirm that water plays an essential role on the specific methane production rate, final methane yield and Volatile Solids (VS) degradation. The final methane yield in semi-dry and dry conditions was 51% and 59% lower for rice straw and 4% and 41% lower for food waste, respectively, if compared with wet conditions. Inhibition tests, based on Volatile Fatty Acid (VFA) analysis, were carried out to investigate the specific inhibition processes that take place with the selected substrates at different TS contents. In wet AD of carrot waste no VFA accumulation was found, and all VFA concentrations were lower than the inhibition limits. A direct correlation between TS content and total VFA (TVFA) concentration was noticed for rice straw and food waste AD. For rice straw a maximum TVFA concentration of 2.1 g/kg was found in dry condition, 1 g/kg in semidry conditions and 0.2 g/kg in wet conditions, whereas for food waste the TVFA concentration was 10 g/kg in dry condition, 9 g/kg in semidry conditions and 3 g/kg in wet conditions. A Mathematical model of complex organic substrate AD in dry and semidry conditions has been proposed to simulate the effect of TS content on the process. The data obtained from batch experiments, in terms of methane production and VFA concentrations, were used to calibrate the proposed model. The kinetic parameters of VFA production and degradation, calibrated using the experimental data, resulted highly dependent on the TS content and different from wet AD literature values. This is due to VFA accumulation in dry conditions, which implies higher values of the inhibition factors introduced in the model. Finally, as dry AD takes usually place in Plug Flow (PF) reactors, an historical and critical review on the role of hydrodynamics in PF bioreactors has been carried out

Anaerobic Treatment of Dairy Wastewater: Impact of Substrate-to-Inoculum Ratio on Biomethane Production

Examining a Pretty Simple and Low Cost Method for Modeling of Biogas Production from Biodegradable Solids

Characterization and evaluation of the anaerobic treatability of a dairy wastewater

Effect of the Substrate to Inoculum Ratios on the Kinetics of Biogas Production during the Mesophilic Anaerobic Digestion of Food Waste

Anaerobic Co-digestion of Expired Dairy Products and Synthetic Domestic Wastewater: Effect on Methane Potential in Batch Reactors

Evaluation of anaerobic co-digestion of dairy manure with food wastes via bio-methane potential assay and CSTR reactor.

Influence of total solid content and inoculum-to-substrate ratio on anaerobic digestion of leaf vegetable waste

Assessment of biomethanation potential and batch kinetics of the anaerobic digestion of vegetable market waste in serum bottles

Use of Continuous Stirred Tank Reactors for Anaerobic Co-Digestion of Dairy and Meat Industry By-Products for Biogas Production

Microbial Community Redundancy and Resilience Underpins High-Rate Anaerobic Treatment of Dairy-Processing Wastewater at Ambient Temperatures

Modeling and forecasting biogas production from anaerobic digestion process for sustainable resource energy recovery

Microbial Analysis and Methane Assessment of Trinary Anaerobic Co-Digestion of Organic Fraction of Municipal Solid Waste

Bio-methanation tests and mathematical modelling to assess the role of moisture content on anaerobic digestion of organic waste

Biomethane production using goat manure and cheese whey: statistical analysis of the effect of mixture composition

Correlation between kinetic parameters, reactor performance, and biogas and methane potential of co-digestion and mono-digestion of active sludge and olive mill wastewater

Optimization of Anaerobic Digestion Model No. 1 (ADM1): Simulation of Dairy Manure Digestion

Effect of Inoculum and Substrate/inoculum Ratio on the Performance and Methanogenic Archaeal Community Structure in Solid State Anaerobic Co-Digestion of Tomato Residues with Dairy Manure and Corn Stover.

Case specific: Addressing co-digestion of wastewater sludge, cheese whey and cow manure: Kinetic modeling

Processing High-Solid and High-Ammonia Rich Manures in a Two-Stage (Liquid-Solid) Low-Temperature Anaerobic Digestion Process: Start-Up and Operating Strategies

Enhancing biomethanation performance through co-digestion of diverse organic wastes: a comprehensive study on substrate optimization, inoculum selection, and microbial community analysis

Evaluating the potential of a new reactor configuration to enhance simultaneous organic matter and nitrogen removal in dairy wastewater treatment