Abstract:Anaerobic digestion and codigestion are processes that may aggregate economic value to the organic waste, not only through the production of biogas, as the main product, but also with a by-product, the digestate. The production of biogas (renewable and sustainable energy source) reduces GEE emissions, as well as the impact caused by waste disposal from the agribusiness sector. The present work aims at the potential optimization biogas production in rice residues (rice straw) in different proportions along with bovine residues (waste), under the effect of temperature increase (from 36 to 60 °C). Preliminary investigation consisted of sampling and drying the residues with analytical tests (TS, VS, COD, TOC, N, P, pH, moisture), which allowed the determination of the proportions to be used in experimental research. Then, anaerobic bench reactors (A, B, C, Control) in different proportions were monitored by means of BMP tests, in order to evaluate the potential of methane production in a period of 60 days. During this period, different temperatures were tested, varying from 36 to 60 °C, gradually increased by 2 to 2 °C, every three or 5 days, in order to adapt the anaerobic microorganisms, present in the waste mass. The three reactors presented different biogas production, which can be explained by the different temperatures proposed. Reactors A (ratio 1:1) and C (ratio 1:10) did not reach the proposed objective as their production level was below the production of the control reactor. The B reactor (3:1 ratio) was the one that presented the highest accumulated biogas production during the test period, with 76.95 NmL and the rice straw contribution of 7.55 NmL. As regarding to temperature, all reactors showed to adapt to the two conditions tested: mesophilic and thermophilic fact that demonstrates synergism among the residues tested. Despite the verified adaptability, the mesophilic condition was defined as the most favorable for biogas production because of its greater stability and lower energy cost. The BMP test has proven them to be a viable, easy-to-use, and inexpensive operational tool to monitor and determine biogas production potential for the waste used.

Investigation and Optimization of Operational Conditions of Anaerobic Digestion Process for Enhanced Biogas Production Yield in a CSTR Using RSM

Examining a Pretty Simple and Low Cost Method for Modeling of Biogas Production from Biodegradable Solids

Optimization of the Process Conditions for Methane Yield from Co-Digestion of Mixed Vegetable Residues and Pig Manure Using Response Surface Methodology

Dry Anaerobic Digestion of the Organic Fraction of Municipal Solid Waste: Biogas Production Optimization by Reducing Ammonia Inhibition

Correlation between kinetic parameters, reactor performance, and biogas and methane potential of co-digestion and mono-digestion of active sludge and olive mill wastewater

Optimization of Operating Parameters for Two-Phase Anaerobic Digestion Treating Slaughterhouse Wastewater for Biogas Production: Focus on Hydrolytic–Acidogenic Phase

Biogas Production Optimization in the Anaerobic Codigestion Process: A Critical Review on Process Parameters Modeling and Simulation Tools

Optimizing Dry Anaerobic Digestion at Pilot Scale for Start-Up Strategy and Long-Term Operation: Organic Loading Rate, Temperature and Co-Digestion.

Improvement of Biogas Production Utilizing a Complex Anaerobic Digestion Model and Gradient-Based Optimization

Processing High-Solid and High-Ammonia Rich Manures in a Two-Stage (Liquid-Solid) Low-Temperature Anaerobic Digestion Process: Start-Up and Operating Strategies

Effect of Temperature Variation on Codigestion of Animal Waste and Agricultural Residue for Biogas Production

Pilot-Scale Anaerobic Digestion of Pig Manure with Thermal Pretreatment: Stability Monitoring to Improve the Potential for Obtaining Methane

Enhancing biogas production from vinasse through optimizing hydraulic retention time and added load using the response surface methodology

Effects of organic loading rate and pretreatments on digestion performance of corn stover and chicken manure in completely stirred tank reactor (CSTR)

A review of response surface methodology for biogas process optimization

Designing and performance evaluation of continuously stirring anaerobic batch reactor for biomethane production from biowaste

Anaerobic Treatment of Dairy Wastewater: Impact of Substrate-to-Inoculum Ratio on Biomethane Production

Influence of Molasses Residue on Treatment of Cow Manure in an Anaerobic Filter with Perforated Weed Membrane and a Conventional Reactor: Variations of Organic Loading and a Machine Learning Application

Dual Optimization in Anaerobic Digestion of Rice Straw: Effects Hrt and Olr Coupling on Methane Production in One-Stage and Two-Stage Systems

Enhancing biomethanation performance through co-digestion of diverse organic wastes: a comprehensive study on substrate optimization, inoculum selection, and microbial community analysis

Modeling and optimization of process parametric interaction during high-rate anaerobic digestion of recycled paper mill wastewater using the response surface methodology