Abstract:Sensitive H-2 gas sensors are highly desirable for the prediction and early-warning of H-2 leakage. Low-dimensional nanostructures of metal oxide semiconductor emerge as promising materials candidates, but it remains a challenge to preserve the nanostructures in the real sensors. In this work, we demonstrated highly sensitive H-2 gas sensors based on porous network of SnO2 nanowires that exhibited ultrasmall diameter similar to 2 nm. Colloidal SnO2 nanowires synthesized via a solvothermal process were drop-coated onto the commercial alumina substrates, followed by in-situ annealing treatment at 350 degrees C to remove the surface ligands. The sensors exhibited sensitive response with linear dependence on the H-2 gas concentration ranging from 2 ppm to 100 ppm when operated at 250 degrees C. Typically, the sensor had a response of 13 toward 40 ppm of H-2, with the response and recovery time being 15 s and 31 s, respectively. To further improve the sensor performance, Palladium doped SnO2 nanowires were thoroughly investigated. It's shown that, the operating temperature of the sensor decreased from 250 degrees C to 150 degrees C after Pd doping, and the response and recovery time decreased to 6 s/3 s. The superb sensitivity was attributed to the enhanced gas reception, electron transport as well as utility factor owing to the network nanostructure of ultrathin SnO2 nanowires and catalytic activity of Pd, according to theoretical calculation and adsorption kinetics studies. Combined with the excellent solution processability, the colloidal SnO2 nanowires are potentially attractive for next-generation gas sensors with lower power consumption and integration with silicon-based substrates.

Investigation of low-temperature deposition of SnO2 thin film for improving sensitivity of LaOCl/SnO2 heterojunction CO2 sensor using electrochemical impedance spectroscopy

Controlling the structure and composition of SnO 2 -based thin film with reactive sputtering to improve the sensitivity of semiconductor CO 2 sensor

Enhanced gas-sensing performance of SnO2/Nb2O5 hybrid nanowires

Enhanced Gas Selectivity Induced by Surface Active Oxygen in SnO/SnO2 Heterojunction Structures at Different Temperatures

Synthesis of SnO2 Quantum Dot Sensitized LaFeO3 for Conductometric Formic Acid Gas Sensors

High Sensitivity Low-Temperature Hydrogen Sensors Based on SnO2/κ(ε)-Ga2O3:Sn Heterostructure

Sensitive H2 Gas Sensors Based on SnO2 Nanowires

Enhanced H 2 S Gas Sensing Performance of SnO 2 /BaSnO 3 Heterostructures

Atomic-level insights into selective adsorption of H2 and CO on SnO2/CoO heterojunctions

Study on Impedance NO_2 Sensor Based on La_0.8Sr_0.2CoO_3 Thick Film

Ultrasensitive Detection and In-Depth Chemical Mechanism Study Toward Ethanol Vapor for LaCoO3/SnO2 Nanoflower

Chemical and Electronic Modulation via Atomic Layer Deposition of NiO on Porous In2O3 Films to Boost NO2 Detection

High sensitivity and fast response sensor for formaldehyde based on In2O3/Sn2O3 heterojunction

Nonstoichiometric Doping of La 0.9 Fe x Sn 1- x O 3 Hollow Microspheres for an Ultrasensitive Formaldehyde Sensor

Temperature-dependent p-n switching for highly selective CO gas sensing based on mixed phases of magnetron sputtered (p)SnO-(n)SnO 2 thin films

Ultralow detection limit MEMS hydrogen sensor based on SnO2 with oxygen vacancies

Preparation of ZrO2-SnO2 thin films by the sol-gel technique and their gas sensitivity

Effect of ZrO2 dopant on the electrical and gas sensing properties of SnO2 thin films prepared by the sol-gel technique

Atomic Layer Deposited SnO2/ZnO Composite Thin Film Sensors with Enhanced Hydrogen Sensing Performance

Defect engineering of nanostructured ZnSnO3 for conductometric room temperature CO2 sensors

In-situ Construction of SnO2 Nanolayer-Sns2 Nanosheets Heterostructures for Enhanced NO2 Sensing at Room Temperature and Their DFT Investigation