Abstract:Background: Microalgae have attracted considerable interest due to their ability to produce a wide range of valuable compounds. Pulsed Electric Fields (PEF) has been demonstrated to effectively disrupt the microalgae cells and facilitate intracellular extraction. To increase the commercial viability of microalgae, the entire biomass should be exploited with different products extracted and valorized according to the biorefinery scheme. However, demonstrations of multiple component extraction in series are very limited in literature. This study aimed to develop an effective lipid extraction protocol from wet Scenedesmus almeriensis after PEF-treatment with 1.5 MJ·kgDW-1. A cascade process, i.e., the valorization of several products in row, was tested with firstly the collection of the released carbohydrates in the water fraction, then protein enzymatic hydrolysis and finally lipid extraction. Biomass processed with high pressure homogenization (HPH) on parallel, served as benchmark. Results: Lipid extraction with ethanol:hexane (1:0.41 vol/vol) offered the highest yields from the different protocols tested. PEF-treatment promoted extraction with almost 70% of total lipids extracted against 43% from untreated biomass. An incubation step after PEF-treatment, further improved the yields, up to 83% of total lipids. Increasing the solvent volume by factor 2 offered no improvement. In comparison, extraction with two other systems utilizing only ethanol at room temperature or elevated at 60 °C were ineffective with less than 30% of total lipids extracted. Regarding cascade extraction, carbohydrate release after PEF was detected albeit in low concentrations. PEF-treated samples displayed slightly better kinetics during the enzymatic protein hydrolysis compared to untreated or HPH-treated biomass. The yields from a subsequent lipid extraction were not affected after PEF but were significantly increased for untreated samples (66% of total lipids), while HPH displayed the lowest yields (~ 49% of total lipids). Conclusions: PEF-treatment successfully promoted lipid extraction from S. almeriensis but only in combination with a polar:neutral co-solvent (ethanol:hexane). After enzymatic protein hydrolysis in cascade processing; however, untreated biomass displayed equal lipid yields due to the disruptive effect of the proteolytic enzymes. Therefore, the positive impact of PEF in this scheme is limited on the improved reaction kinetics exhibited during the enzymatic hydrolysis step.

Enhancement of biomass production and bio-products extraction from microalgae using non-thermal plasma process toward biofuel production

In Situ Ethyl Ester Production from Wet Algal Biomass under Microwave-Mediated Supercritical Ethanol Conditions

Hydrothermal microwave processing of microalgae as a pre-treatment and extraction technique for bio-fuels and bio-products

Combination of cell disruption method and pH variation as pre-treatment for lipid extraction of Nannochloropsis sp.

Analysis of the lipid extraction performance in a cascade process for Scenedesmus almeriensis biorefinery

Exploring non-thermal plasma technology for microalgae removal

Optimization of Microalgal Bead Preparation with Scenedesmus Obliquus for Both Nutrient Removal and Lipid Production

NMR techniques for determination of lipid content in microalgal biomass and their use in monitoring the cultivation with biodiesel potential

Effects of Pulsed Electric Field Treatment on Enhancing Lipid Recovery from the Microalga, Scenedesmus.

Utilization of Tannery Wastewater for Biofuel Production: New Insights on Microalgae Growth and Biomass Production

Direct Enzymatic Ethanolysis of Potential Nannochloropsis Biomass for Co-Production of Sustainable Biodiesel and Nutraceutical Eicosapentaenoic Acid

Hydrothermal Cell Disruption of Nannochloropsis Sp. and Its Influence on Lipid Extraction

Optimized extraction of neutral carbohydrates, crude lipids and photosynthetic pigments from the wet biomass of the microalga Scenedesmus obliquus BR003

Domestic Wastewater Treatment and Biofuel Production by Using Microalga Scenedesmus Sp. ZTY1.

A novel nanoemulsion-based microalgal growth medium for enhanced biomass production

Photothermal technique-enabled ambient production of microalgae biodiesel: Mechanism and life cycle assessment

Improved Aqueous Extraction of Microalgal Lipid by Combined Enzymatic and Thermal Lysis from Wet Biomass of Nannochloropsis Oceanica.

Improvising Biodiesel Production from Scenedesmus dimorphus via Nutrient Starvation and Optimized Pretreatment Process

In Situ Enzymatic Conversion of Nannochloropsis oceanica IMET1 Biomass into Fatty Acid Methyl Esters

Microalgae biomass pre-treatment with deep eutectic solvent to optimize lipid isolation in biodiesel production

Pretreatment of microalgal biomass for enhanced recovery/extraction of reducing sugars and proteins