Stripping-struvite precipitation combined process for treating high ammonia-nitrogen wastewater generated by the craft of vanadium extraction

siqin zhu,Guohua Ye,xuanxiong kang

DOI: https://doi.org/10.1039/d3ew00411b

2023-10-08

Environmental Science Water Research & Technology

Abstract:Direct discharge of high ammonia-nitrogen (NH3-N) wastewater generated during vanadium extraction can cause serious pollution of ecosystems. The results of this study indicate that the optimal process conditions are as follows: NH3-N wastewater pretreated by the stripping method In the first stage, with an initial pH of 11, stripping temperature of 40°C, and gas-liquid ratio of 3600 (L/L); the second stage is struvite precipitation method, with a reaction temperature of 25°C, pH of 9.5, n(Mg2+):n(NH4+) ratio of 1.15, n(PO43-):n(NH4+) ratio of 1.05, and a precipitation time of 25 minutes. Under these optimal conditions, the recovery of ammonia nitrogen in the first stage can reach 90.61% (reduced from 23941 mg/L to 2249 mg/L). In the second stage, Using response surface methodology, the main influencing factors were optimized, and a high-fitting quadratic response surface model was obtained. This optimization leads to an ammonia nitrogen recovery reached 95.5% (reducing ammonia nitrogen content from 2249 mg/L to 101 mg/L).The final precipitate analysis showed that struvite (magnesium ammonium phosphate, MAP) crystals were the main component, with higher purity, which could be used as a compound fertilizer. The study showed that the combined process of stripping and struvite precipitation can effectively remove ammonia nitrogen from high-concentration ammonia nitrogen wastewater generated during vanadium extraction and that the reaction conditions optimized by response surface methodology have good operability and accuracy.

environmental sciences,engineering, environmental,water resources