Charcoal production from four tropical woods through slow pyrolysis under different temperatures: yield of different products and condition of pyrolysis into the reactor

Roger Moya,Carolina Tenorio,Jaime Quesada-Kimzey

DOI: https://doi.org/10.1007/s13399-024-05366-y

IF: 4.05

2024-02-11

Biomass Conversion and Biorefinery

Abstract:Costa Rica produces an extensive amount of forest residues, which can be pyrolyzed slowly to produce by-products like charcoal, wood vinegar, bio-oil, and non-condensable that can be effectively used in agricultural crops, providing a comprehensive approach to leveraging forest resources for finding renewable sources for agriculture production. However, there is a lack of information about the processes and products obtained with slow pyrolysis of forest residues in Costa Rica. Hence, this study aims to ascertain the yield of a diverse range of pyrolysis products and assess the performance of a small pilot reactor for slow pyrolysis of four tropical woods at five varying temperatures (300, 350, 400, 450, and 500 °C). The results showed that charcoal yields ranged from 28.2 to 56.6%, bio-oil from 2.8 to 8.1%, whereas yields of non-condensable varied from 14.0 to 33%, and wood vinegar yields ranged between 25.6 to 40.8%. Another significant finding indicated that due to incomplete pyrolysis of parentwood, the temperatures of 300–350 °C were deemed suboptimal and are thus not recommended. Charcoal yields were consistent between 400 and 500 °C. Condensable (wood vinegar and bio-oil) and non-condensable gases were at their maximum at 500 °C; however, the production of charcoal was the lowest, and the charcoal was brittle. The four tropical wood species exhibited divergent performances, as Gmelina arborea and Dipteryx panamensis performed differently than Hieronyma alchornoides and Tectona grandis . Though G. arborea produced a higher percentage of non-condensable gases, challenges were encountered in the separation of wood vinegar and bio-oil. While D. panamensis produced a low charcoal yield, it benefitted from the highest percentage of condensable gases. T. grandis and H. alchornoides produced similar percentages of different products and temperatures within the reactor. D. panamensis parentwood exhibited a slower initiation of the pyrolysis process, maintaining higher temperatures than the other species during this process, just like T. grandis and H. alchornoides . G. arborea parentwood showcased a beginning of pyrolysis similar to the other species but exhibited the longest pyrolysis time at varying temperatures.

energy & fuels,engineering, chemical