Abstract:In this paper, the substitution of different amounts of Zr for Ti in the hydrogen storage electrode alloy Mg35Ti10Ni55 has been carried out for the purpose of further improving the electrochemical performance of the electrode alloy. The electrochemical properties were tested on the purposely prepared Mg35Ti10−xZrxNi55 (x=1, 3, 5, 7, 9) electrode alloys. The results showed that all alloys substituted with Zr possessed a higher cycling capacity retention and a larger initial discharge capacity (except Mg35Ti1Zr9Ni55) than the original alloy Mg35Ti10Ni55. Among these alloys Mg35Ti5Zr5Ni55 exhibited the highest discharge capacity and cycling stability. It was found from X-ray Photoelectron Spectroscopy (XPS) surface analysis that the Zr content reduced the degree of oxidation of Mg. The higher the Zr content, the lower is the degree of oxidation of Mg. Auger electron spectroscopy (AES) analysis revealed that the thickness of the passive oxide film coating on the alloy surfaces became first reduced as the Zr content increased but subsequently became augmented as the Zr content exceeded 5 at.%. The study indicated that the corrosion inhibiting effect of Zr alone, without the presence of Ti was weak. The synergetic effect of Zr and Ti made the passive film more compact, less pervious and more protective than by Ti or Zr alone. The thickness of the passive film agreed well with the polarization resistance of the alloys obtained from electrochemical impedance spectroscopy (EIS) Nyquist diagrams, suggesting that the surface polarization resistance RP being closely related to the film thickness and the exchange current density on the surface of the alloy varied accordingly. The conclusion of this study is that 5 at.% Zr substitution in Mg35Ti10Ni55 leads to the formation on the surface of a good and thin passive film, which retards the corrosion of the alloy and at the same time leads to the least polarization resistance and highest exchange current in this series of alloys studied.

Electrochemical Degradation of the Hydrogen-Absorption-Induced Passive Film on an Ni–Ti Superelastic Alloy in an NaCl Solution

Electrochemical Hydrogen Charging on Corrosion Behavior of Ti-6Al-4V Alloy in Artificial Seawater

Electrochemical study on the effect of hydrogen on the passive film of selective laser melted 316L stainless steel in a proton exchange membrane water electrolyzer environment

Effect of electrochemical hydrogen charging on the mechanical property and corrosion behavior of Ti-3Mo alloy

Hydrogen charging effects on the alternation of oxide film formed on Ni, Cr and Alloy 690 in high-temperature water

Effect of Hydrogen Charging Conditions on Hydrogen Blisters and Pitting Susceptibility of 445J1M Ferritic Stainless Steel

The effect of hydrogen on the passivity of iron-based and nickel-based amorphous alloys

The effect of partial substitution of Zr for Ti on the electrochemical properties and surface passivation film of Mg35Ti10 - xZrxNi55 (x=1, 3, 5, 7, 9) electrode alloys

The effect of temperature on the electrode properties of the directly prepared Ti3Ni2 alloy

Electrochemical Investigations of Activation and Degradation of Hydrogen Storage Alloy Electrodes in Sealed Ni/MH Battery

The Effects of Partial Substitution of Mn by Cr on the Phase Structure, Microstructure and Electrochemical Properties of Ti-Zr-V-Mn-Ni Hydrogen Storage Alloys

Modification of Hydrogenation and Corrosion Properties of Hydrogen Storage Material by Amorphous TiCrFeCoNi HEA Layer

Hydrogen adsorption on hydrogen storage alloy surface and electrochemical performances of the MlNi4.0Co0.6Al0.4 alloy electrodes before and after surface treatment

Degradation Mechanisms of Ti–V-based Multiphase Hydrogen Storage Alloy Electrode

Effect of surface modification on performance of alloy electrodes for hydrogen storage

Effects of Hydrogen on Semiconductivity of Passive Films and Corrosion Behavior of 310 Stainless Steel

Effect of hydrogen charging on the corrosion behavior of a body-centered cubic FeCrV medium entropy alloy

Effect of hydrogen on super-elastic behavior of NiTi shape memory alloy wires: Experimental observation and diffusional-mechanically coupled constitutive model

Effects of Electrochemical Hydrogen Charging Parameters on the Mechanical Behaviors of High-Strength Steel

Effects of Applied Cathodic Current on Hydrogen Infusion, Embrittlement, and Corrosion-Induced Hydrogen Embrittlement Behaviors of Ultra-High Strength Steel for Automotive Applications

Hydrogen-induced Degradation of PMN-based Relaxor Ferroelectrics During Nickel Electroplating