Abstract:Waste cooking oil (WCO) is a readily available and cheap feedstock for biodiesel production. However, WCO contains high levels of free fatty acids (FFAs), which negatively impact the biodiesel yield if homogeneous catalysts are used. Heterogeneous solid acid catalysts are preferred for low-cost feedstocks because the catalysts are highly insensitive to high levels of FFA in the feedstock. Therefore, in the present study, we synthesized and evaluated different solid catalysts, pure β-zeolite, ZnO-β-zeolite, and SO42-/ZnO-β-zeolite for the production of biodiesel using WCO as feedstock. The synthesized catalysts were characterized by Fourier transform infrared spectroscopy (FTIR), pyridine-FTIR, N2 adsorption-desorption, X-ray diffraction, thermogravimetric analysis, and scanning electron microscopy, while the biodiesel product was analyzed using nuclear magnetic resonance (1H and 13C NMR) and gas chromatography-mass spectroscopy. The results revealed that the SO42-/ZnO-β-zeolite catalyst showed excellent catalytic performance for simultaneous transesterification and esterification of WCO, with a higher percentage conversion than the ZnO-β-zeolite and pure β-zeolite catalyst, due to the large pore size and high acidity. The SO42-/ZnO-β-zeolite catalyst exhibits 6.5 nm pore size, a total pore volume of 0.17 cm3/g, and high surface area of 250.26 m2/g. Experimental parameters such as catalyst loading, methanol:oil molar ratio, temperature, and reaction time were varied in order to establish the optimal parameters. The highest WCO conversion of 96.9% was obtained using the SO42-/ZnO-β-zeolite catalyst under an optimum reaction condition of 3.0 wt % catalyst loading, 200 °C reaction temperature, and 15:1 molar ratio of methanol to oil in 8 h reaction time. The WCO-derived biodiesel properties conform to the ASTM6751 standard specification. Our investigation of its kinetics revealed that the reaction follows a pseudo first-order kinetic model, with an activation energy (Ea) of 38.58 kJ/mol. Moreover, the stability and reusability of the catalysts were evaluated, and it was found that the SO42-/ZnO-β-zeolite catalyst exhibited good stability, giving a biodiesel conversion of over 80% after three synthesis cycles.

Catalytic Performance Investigation of Alkali and Bifunctional Catalysts Derived from Lignocellulosic Biomasses for Biodiesel Synthesis from Waste Frying Oil

Potassium and zirconium promoted coffee husk ash catalysts for waste frying oil methanolysis: Kinetic and thermodynamic studies

KNO3-Loaded Coffee Husk Ash as a Heterogeneous Alkali Catalyst for Waste Frying Oil Valorization into Biodiesel

Biodiesel Production from Waste Frying Oil (WFO) Using a Biomass Ash-Based Catalyst

[Influence of ZSM-5(38)/Al-MCM-41 Composite Molecular Sieve Catalysts on Pyrolysis of Cellulose].

Ultrasound-assisted dispersion of bifunctional CaO-ZrO 2 nanocatalyst over acidified kaolin for production of biodiesel from waste cooking oil

Biodiesel production from waste cooking oil using a heterogeneous catalyst from pyrolyzed rice husk

Biodiesel Production from Waste Frying Oil using Catalysts Derived from Waste Materials

Biodiesel Production from Waste Cooking Oil via β-Zeolite-Supported Sulfated Metal Oxide Catalyst Systems

Synthesis of MIL-68 (Al) Catalyst and Optimization of Green Biodiesel Production from Waste Cooking Oil

Lignosulfonate‐based Carbon‐supported Pellets Catalyst to Enhance Sustainable Biofuel Production from Waste Cooking Oil

Preparation of sulfonated lignin-based carbon aerogel catalyst for biodiesel production from waste vegetable oil

Biodiesel synthesis via heterogeneous catalysis: application of new material based on mixed oxides (Na-FeAlO) obtained from the microstructural transformation of red mud

Intensification of Biodiesel Processing from Waste Cooking Oil, Exploiting Cooperative Microbubble and Bifunctional Metallic Heterogeneous Catalysis

Catalytic evaluation of eggshell‐based calcium methoxide over Al2O3 for biodiesel generation from waste cooking oil

Synthesis of a novel acid-base bifunctional Zn/Ca–Zr catalyst for biodiesel application: Experimental and molecular simulation studies

Effect of H-ZSM-5 and Al-MCM-41 Proportions in Catalyst Mixtures on the Composition of Bio-Oil in Ex-Situ Catalytic Pyrolysis of Lignocellulose Biomass

Immobilization of Potassium-Based Heterogeneous Catalyst over Alumina Beads and Powder Support in the Transesterification of Waste Cooking Oil

Biodiesel production from agricultural biomass wastes: Duroc breed fat oil, Citrillus lanatus rind, and Sorghum Bagasse

Synthesis of Alumina-Supported Chicken Eggshell Catalyst for Transesterification of Waste Cooking Oil

Valorization of hazardous waste cooking oil for the production of eco-friendly biodiesel using a low-cost bifunctional catalyst