Preparation of sulfonated lignin-based carbon aerogel catalyst for biodiesel production from waste vegetable oil

Zayed Al-Hamamre,Ibrahem Altarawneh,Mohammad Alnaief,Arwa Sandouqa,Rasha Alhammouri

DOI: https://doi.org/10.1080/15435075.2024.2429776

IF: 3.206

2024-11-27

International Journal of Green Energy

Abstract:Using effective green heterogeneous catalysts to produce biodiesel from inexpensive non-food oils is vital for reducing reliance on fossil fuels, meeting increasing global energy demands, and supporting carbon neutrality. This study explores the use of a sulfonated lignin-based carbon aerogel catalyst for biodiesel production from waste vegetable oil (WVO). The catalyst, prepared via a sol–gel method followed by carbonization and sulfonation exhibited a specific surface area of 78.16 m 2 /g and a -SO3H group density of 2.81 ± 0.14 mmol/g, which served as the primary active sites. Under optimal conditions; 10 wt% catalyst loading, a 45:1 methanol-to-WVO molar ratio, 65°C reaction temperature, and 5-hr reaction time, the catalyst achieved a maximum biodiesel conversion of 93.3% and a biodiesel yield of 88.51%. However, a decline in performance was observed over repeated cycles, with conversion dropping to 51.68% by the fourth cycle, attributed to the leaching of -SO3H groups and a reduction in surface area to 44.13 m 2 /g. The decrease in the sulfonic group density from 2.81 ± 0.14 to 1.03 ± 0.11 mmol SO3H g − 1 indicated a loss of active sites, highlighting the need to improve the active sites' stability and the catalyst's structural integrity. The produced biodiesel met ASTM D6751 and EN 14,214 standards, demonstrating the catalyst's effectiveness for sustainable biodiesel production.

energy & fuels,thermodynamics,green & sustainable science & technology