Abstract:The extensive use of steel spring floating slab tracks has effectively addressed the challenge of alleviating the environmental vibrations induced by urban rail transit systems. However, under the combined action of train dynamic loads and complex environmental factors, problems, such as the fracture of steel spring vibration isolators and suspension vibrations induced by the uneven settlement of the base, often occur. The failure of isolator support stiffness is often hidden in its early stages and is challenging to identify by conventional detection methods. At the same time, it will aggravate the wheel–rail interaction, accelerate the deterioration of track structure, and even affect the driving safety. This study first establishes a detailed coupled train-floating slab track-foundation analytical model. Then the influence of the vibration isolator support stiffness failure on the dynamic indices of the floating slab track system response is analyzed. A set of defect identification methods that can detect the number of failed steel springs, severity of damage, and their location is proposed. Finally, an intelligent monitoring system for support stiffness of floating slab track is built by combining the density-based spatial clustering of applications with noise algorithm and statistical data analysis and is applied to a rail line in southern China. During a three-year monitoring campaign, a suspension failure and a fracture of a steel spring were each successfully detected and detailed failure information was obtained. Field investigation results were consistent with the damage identification results. After repair, the track structure dynamic response returned to the average pre-damage level and further deterioration had been arrested. The proposed damage identification methods and monitoring system provide an approach for intelligent identification of track structure support stiffness failures.

A condition monitoring approach for the detection of defects in the primary suspension of railway vehicles

Condition Monitoring of the Dampers in the Railway Vehicle Suspension Based on the Vibrations Response Analysis of the Bogie

Monitoring the bogie lateral dynamics of a high-speed train through wireless sensor nodes

Condition monitoring for train suspension system based on cross-correlation

An Automated System for Position Monitoring and Correction of Chord-Based Rail Corrugation Measuring Points

On the use of transmissibility for the detection of damaged springs in the primary suspension of a locomotive

Fault Diagnosis of Rail Vehicle Suspension Systems by Using Glrt

Urban rail track condition monitoring based on in-service vehicle acceleration measurements

Design and Performance Analysis of the Hydropneumatic Suspension System for a Novel Road-Rail Vehicle

Research on Fault Detection and Isolation of Railway Vehicle Suspension System by Impulse Track Irregularity

Analysis of the axial and transversal stiffness of an air spring suspension of a railway vehicle: mathematical modelling and experiments

Failure analysis for air spring systems of urban rail vehicles considering load spectrum

New methods for the condition monitoring of level crossings

Modelling and Dynamic Analysis of Adaptive Neuro-Fuzzy Inference System-Based Intelligent Control Suspension System for Passenger Rail Vehicles Using Magnetorheological Damper for Improving Ride Index

Adaptive optimal control of pneumatic suspensions for comfort improvement of flexible railway vehicles using Monte Carlo simulations

A method for support stiffness failure identification in a steel spring floating slab track of urban railway: a case study in China

Fatigue stress estimation of metro bogie frame through frequency response functions by using limited sensors

Identification of track irregularities with the multi-sensor acceleration measurements of vehicle dynamic responses

Research on Performance Degradation Prediction of Urban Rail Vehicle Suspension System

Sensor fault detection of vehicle suspension systems based on transmissibility operators and Neyman–Pearson test

ToMFIR-based incipient fault detection and estimation for high-speed rail vehicle suspension system