Abstract:Supercritical CO2 (S-CO2) power cycles have demonstrated significant performance improvements in concentrated solar and nuclear applications. These cycles promise an increase in thermal-to-electric conversion efficiency of up to 50% over conventional gas turbines (Wright, S., 2012, “Overview of S-CO2 Power Cycles,” Mech. Eng., 134(1), pp. 40–43), and have become a priority for research, development, and deployment. In these applications the CO2 is compressed to pressures above the critical value using radial compressors. The thermodynamic state change of the working fluid is close to the critical point and near the vapor–liquid equilibrium region where phase change effects are important. This paper presents a systematic assessment of condensation on the performance and stability of centrifugal compressors operating in S-CO2. The approach combines numerical simulations with experimental tests. The objectives are to assess the relative importance of two-phase effects on the internal flow behavior and to define the implications for radial turbomachinery design. The condensation onset is investigated in a systematic manner approaching the critical point. A nondimensional criterion is established that determines whether condensation might occur. This criterion relates the time required for stable liquid droplets to form, which depends on the expansion through the vapor–pressure curve, and the residence time of the flow under saturated conditions. Two-phase flow effects can be considered negligible when the ratio of the two time scales is much smaller than unity. The study shows that condensation is not a concern away from the critical point. Numerical two-phase calculations supported by experimental data indicate that the timescale associated with nucleation is much longer than the residence time of the flow in the saturated region, leaving little opportunity for the fluid to condense. Pressure measurements in a converging diverging nozzle show that condensation cannot occur at the level of subcooling characteristic of radial compressors away from the critical point. The implications are not limited to S-CO2 power cycles but extend to applications of radial machines for dense, saturated gases. In the immediate vicinity of the critical point, two-phase effects are expected to become more prominent due to longer residence times. However, the singular behavior of thermodynamic properties at the critical point prevents the numerical schemes from capturing important gas dynamic effects. These limitations require experimental assessment, which is the focus of ongoing and future research.

Effect of relative humidity on the nozzle performance in non-equilibrium condensing flows for improving the compressed air energy storage technology

Numerical study of heterogeneous condensation in the de Laval nozzle to guide the compressor performance optimization in a compressed air energy storage system

Experimental investigation on the performance of compressed air energy storage using spray-based heat transfer

Water spray heat transfer gas compression for compressed air energy system

Thermodynamic Investigation of Variable-Speed Compression Unit in Near-Isothermal Compressed Air Energy Storage

A Study of Moist Air Condensation Characteristics in a Transonic Flow System

Influence of Boundary Effect on Supersonic Flows and Non-Equilibrium Condensation in a Laval Nozzle for Natural Gas Dehydration

Liquid-gas Heat Transfer Characteristics of Near Isothermal Compressed Air Energy Storage Based on Spray Injection

Dimensionless Thermal Performance Analysis of a Closed Isothermal Compressed Air Energy Storage System with Spray-Enhanced Heat Transfer

The Prediction of Condensation Characteristics of Supercritical Carbon Dioxide in the Laval Nozzle During Supersonic Flow

Comparative Analysis of Diagonal and Centrifugal Compressors with Synergy Theory in Compressed Air Energy Storage System

Compression Performance Optimization Considering Variable Charge Pressure in an Adiabatic Compressed Air Energy Storage System

Research on the performance characteristics of an oil-free scroll expander that is applied to a micro-scale compressed air energy storage system

Efficiency Analysis of an Arrayed Liquid Piston Isothermal Air Compression System for Compressed Air Energy Storage

Performance Analysis of a Compressed Humid Air Energy Storage System

Numerical simulation on the effect of non-condensable gas on direct contact condensation of steam jet in a narrow pipe

Quantitative and Qualitative Experimental Assessment of Water Vapor Condensation in Atmospheric Air Transonic Flows in Convergent–Divergent Nozzles

Research on the influence of initial parameters of water droplets on the performance of counter-rotating axial-flow compressor

An Investigation of Condensation Effects in Supercritical Carbon Dioxide Compressors

Investigation of heterogeneous condensation flow characteristics in the steam turbine based on homogeneous-heterogeneous condensation coupling model using OpenFOAM

Decoupling heat-pressure potential energy of compressed air energy storage system: Using near-isothermal compressing and thermal energy storage