Abstract:Supercritical CO2 (S-CO2) power cycles have demonstrated significant performance improvements in concentrated solar and nuclear applications. These cycles promise an increase in thermal-to-electric conversion efficiency of up to 50% over conventional gas turbines (Wright, S., 2012, “Overview of S-CO2 Power Cycles,” Mech. Eng., 134(1), pp. 40–43), and have become a priority for research, development, and deployment. In these applications the CO2 is compressed to pressures above the critical value using radial compressors. The thermodynamic state change of the working fluid is close to the critical point and near the vapor–liquid equilibrium region where phase change effects are important. This paper presents a systematic assessment of condensation on the performance and stability of centrifugal compressors operating in S-CO2. The approach combines numerical simulations with experimental tests. The objectives are to assess the relative importance of two-phase effects on the internal flow behavior and to define the implications for radial turbomachinery design. The condensation onset is investigated in a systematic manner approaching the critical point. A nondimensional criterion is established that determines whether condensation might occur. This criterion relates the time required for stable liquid droplets to form, which depends on the expansion through the vapor–pressure curve, and the residence time of the flow under saturated conditions. Two-phase flow effects can be considered negligible when the ratio of the two time scales is much smaller than unity. The study shows that condensation is not a concern away from the critical point. Numerical two-phase calculations supported by experimental data indicate that the timescale associated with nucleation is much longer than the residence time of the flow in the saturated region, leaving little opportunity for the fluid to condense. Pressure measurements in a converging diverging nozzle show that condensation cannot occur at the level of subcooling characteristic of radial compressors away from the critical point. The implications are not limited to S-CO2 power cycles but extend to applications of radial machines for dense, saturated gases. In the immediate vicinity of the critical point, two-phase effects are expected to become more prominent due to longer residence times. However, the singular behavior of thermodynamic properties at the critical point prevents the numerical schemes from capturing important gas dynamic effects. These limitations require experimental assessment, which is the focus of ongoing and future research.

The Prediction of Condensation Characteristics of Supercritical Carbon Dioxide in the Laval Nozzle During Supersonic Flow

Research on Condensation Characteristics of Supercritical Carbon Dioxide in Laval Nozzle Considering Working Condition of Power Cycles

Numerical Studies of Nitrogen Spontaneous Condensation Flow in Laval Nozzles Using Varying Droplet Growth Models

A Study of Moist Air Condensation Characteristics in a Transonic Flow System

Condensation and expansion characteristics of water steam and carbon dioxide in a Laval nozzle

A Robust Computational Model for Simulating Supercritical Co2 Non-Equilibrium Condensation Flows

Analysis of Non-Equilibrium Condensation Characteristics of Supercritical Carbon Dioxide During Transonic Flow in the Laval Nozzle

Numerical Study on CO2 Non-Equilibrium Condensation Considering Shock Waves for the Potential of Flue Gas Decarbonization

Effect of Vapour Condensation on Hot Steam Ejector System of Supersonic Wind Tunnel

Numerical study of heterogeneous condensation in the de Laval nozzle to guide the compressor performance optimization in a compressed air energy storage system

Numerical Research on Nitrogen Spontaneous Condensation in Converging-Diverging Nozzle

Numerical simulation of condensation of supercritical water gasification products in a supersonic nozzle

Numerical Study on the Nano-Droplets Formation Process from Superheated Steam Condensation Flow Effected by Nozzle Convergent Profile

An Investigation of Condensation Effects in Supercritical Carbon Dioxide Compressors

Numerical Study of the Effct of Nozzle Configuration on Supersonic Condensation Jet

Study on supersonic swirling condensation characteristics of CO2 in Laval nozzle

Non-equilibrium Condensation in Flue Gas and Migration Trajectory of CO2 Droplets in a Supersonic Separator

Numerical Investigation for Non-Equilibrium Condensation Two-Phase Flow in Cryogenic Turbo-Expander

The effect of the inlet steam superheat degree on the non-equilibrium condensation in steam turbine cascade

Simulation of Laval-Type Nozzle for Applications in Power Generation and Power-to-Electrical Systems

Numerical study on the influence of supersonic nozzle structure on the swirling condensation characteristics of CO2