Abstract:The effect of several solvents present in a biphasic reaction system on cells of Rhodococcus erythropolis DCL14, Xanthobacter Py2, Arthrobacter simplex and Mycobacterium sp. NRRL B-3805 was evaluated. These four strains have been widely exploited, from bioremediation to the production of fine chemicals, in two-phase reaction media. The solvents tested were ethyl butyrate, n-hexane, cyclohexane, iso-octane, n-dodecane, DMSO, bis(2-ethylhexyl) phthalate and fluorinert FC-70. The cell population was monitored by fluorescence microscopy and analysis of the images captured provided single-cell-level information on cell viability, morphological factors of both viable and non-viable cells, and on the number of viable cells in clusters. These data, and those concerning the initial carveol concentration, the carbon source used during growth, the adaptation time to the solvent prior to substrate addition, and the properties of the organic solvent, were interpreted using principal components analysis (PCA). For R. erythropolis, X. Py2, and A. simplex, between 70.1 and 80.4% of the variability of the data could be explained by six principal components, while 86.7% of the variance in the results obtained with Mycobacterium sp. could be represented by seven principal components. In all cases, solvent toxicity could explain over a third of the variability in the data. R. erythropolis cells were able to maintain their viability under harsh conditions. A period of contact between cells and solvent, prior to the addition of substrate, was prejudicial for R. erythropolis and A. simplex cells, at least for the most toxic solvents, but was beneficial for X. Py2 cells. The number of Mycobacterium sp. cells in clusters was lower after an adaptation period compared to the number of cells in aggregates when the substrate was added at time zero. The substrates transformed by R. erythropolis and A. simplex cells increased the toxicity of the system by decreasing the log P of the reaction mixture. Hydrocortisone was responsible for a reduction in the ability of A. simplex to respond to stress conditions. Mycobacterium sp. cells were apparently unaffected by beta-sitosterol. The results obtained are useful for the design of more efficient two-phase reaction systems where solvent toxicity may be overcome in order to increase cell productivity.

Phase toxicity of dodecane on the microalga Dunaliella salina

Selective extraction of carotenoids from the microalga Dunaliella salina with retention of viability

Continuous production of carotenoids from Dunaliella salina

Solvent toxicity in organic-aqueous systems analysed by multivariate analysis

Generation of Volatile Compounds from Carotenoids of Dunaliella bardawil Algae by Water Bath Heating and Microwave Irradiation

β-Carotene extraction from Dunaliella salina by supercritical CO2

Cell Disruption and Pressurized Liquid Extraction of Carotenoids from Microalgae

Direct Extraction of Lipids, β-Carotene, and Polyphenolic Compounds from Wet Microalga Dunaliella salina by Liquefied Dimethyl Ether

EXPERIMENTAL RESEARCH ON DIRECT LIQUEFACTION OF MICROALGAE IN SUBCRITICAL/SUPERCRITICAL WATER

Effectiveness of Dunaliella salina Extracts against Bacillus subtilis and Bacterial Plant Pathogens

Ultrasound assisted extraction of Nannochloropsis : Effects on lipid extraction efficiency and lipid stability

Interplay between interfacial behaviour, cell structure and shear enables biphasic lipid extraction from whole diatom cells (Navicula sp.)

THE EXTRACTION OF OIL FROM Nannochloropsis sp. MICROALGAE USING ULTRASONIC AND FERMENTATION AS CELL DISRUPTION

Toxic effects of chemical pesticides (trichlorfon and dimehypo) on Dunaliella salina

Toxic effects of Fe2WO6 nanoparticles towards microalga Dunaliella salina: Sonochemical synthesis nanoparticles and investigate its impact on the growth

Screening of Biocompatible Organic Solvents for Enhancement of Lipid Milking from Nannochloropsis Sp.

Distributions of organic compounds to the products from hydrothermal liquefaction of microalgae

Effect of Organic Solvents on Microalgae Growth, Metabolism and Industrial Bioproduct Extraction: A Review

Development of a microwave‐assisted solvent extraction process for the extraction of high‐value carotenoids from Chlorella biomass

Hydrothermal Liquefaction Phase Behavior of Microalgae & Model Compounds in Fused Silica Capillary Reactor

The Effect of Dichloromethane on Product Separation during Continuous Hydrothermal Liquefaction of <i>Chlorella vulgaris</i> and Aqueous Product Recycling for Algae Cultivation