Abstract:The human body can easily convert β‐carotene into retinol (a precursor of vitamin A), a significant ingredient in dietary supplements. The need for commercial natural pigment production, including β‐carotene, has led to intensive research in this area. Processing after biosynthesis is a vital stage that involves the use of nontoxic solvents, efficient mechanical disruption of cells, and the isolation of the required compounds. With the growing popularity of green extraction methods and the increasing market demand for carotenoids due to their health benefits, the use of clean, nontoxic, flash‐hydrolyzed biomass for carotenoid production presents a significant advantage. Furthermore, the remaining biomass can serve as a protein source for animal feed, thereby aligning with the principles of the biorefinery concept. In this study, our aim was to optimize the disruption of cells in two microalgal species using flash hydrolysis (FH). We applied two distinct levels of pressure and four separate temperature conditions over a brief residence time. Following this, we employed an ethanol extraction method to assess the efficiency of carotenoid pigment extraction. Flash hydrolysis is a chemical‐free subcritical water‐based continuous‐flow process, injected with wet biomass slurry at a high temperature (150–250 °C) for a very short time (8–12 s) to obtain bioproducts. In this study, we discovered that the pigment β‐carotene constituted 0.04 to 0.3% of the dry biomass in the case of Chlorella vulgaris. Bands of lutein and zeaxanthin were also observed in the thin layer chromatography (TLC) analysis of the treated slurry. This was achieved under conditions of an effective temperature of 200 °C and a pressure of 1700 psi. The Arthrospira platensis (1Tex), β‐carotene yield was 0.014 to 0.021% of dry biomass. Some lutein and zeaxanthin bands were also found in the treated slurry with an effective temperature of 150 °C and 1000 psi pressure. This study reports pigment extraction by FH for the first time. It is a viable process to scale up high‐value natural products like carotenoids from microalgae at the industrial level without adverse environmental impacts. Due to low residence time, the temperature does not have a negative effect on pigments; cell rupture was accomplished effectively using water as a solvent. A considerable amount of pigment could be recovered from microalgae at specific combinations of temperature and pressure depending on the type of cell wall that microalgae possess.

Selective extraction of carotenoids from the microalga Dunaliella salina with retention of viability

Separation And Purification Of Beta-Carotene From Chlorophyll Factory Residues

β-Carotene extraction from Dunaliella salina by supercritical CO2

Continuous production of carotenoids from Dunaliella salina

Cell Disruption and Pressurized Liquid Extraction of Carotenoids from Microalgae

Direct Extraction of Lipids, β-Carotene, and Polyphenolic Compounds from Wet Microalga Dunaliella salina by Liquefied Dimethyl Ether

Pressurized extraction of unsaturated fatty acids and carotenoids from wet Chlorella vulgaris and Phaeodactylum tricornutum biomass using subcritical liquids

Phase toxicity of dodecane on the microalga Dunaliella salina

A novel method of flash‐hydrolysis assisted pigment extraction (carotenoids) from microalgae biomass

Factors affecting production of beta-carotene from Dunaliella salina microalgae

Development of a microwave‐assisted solvent extraction process for the extraction of high‐value carotenoids from Chlorella biomass

Sustainable Carotenoid Extraction from Macroalgae: Optimizing Microwave-Assisted Extraction Using Response Surface Methodology

Alternative green solvents associated with ultrasound-assisted extraction: A green chemistry approach for the extraction of carotenoids and chlorophylls from microalgae

Development of a new method for simultaneous extraction of chlorophylls and carotenoids from microalgal biomass

Selective recovery and purification of carotenoids and fatty acids from Rhodotorula glutinis using mixtures of biosolvents

Continuous Cultivation of Dunaliella Salina in Photobioreactor for the Production of Β-Carotene

Effective solvents and extraction periods employed in phytoplankton carotenoid and chlorophyll determinations

Genomics and transcriptomics reveal β-carotene synthesis mechanism in Dunaliella salina

Ultrasound-Assisted Extraction of Nannochloropsis oculata with Ethanol and Betaine: 1,2-Propanediol Eutectic Solvent for Antioxidant Pigment-Rich Extracts Retaining Nutritious the Residual Biomass

Ultrasound-Enhanced and Microwave-Assisted Extraction of Lipid from Dunaliella Tertiolecta and Fatty Acid Profile Analysis

An efficient method for the sequential production of lipid and carotenoids from the Chlorella Growth Factor-extracted biomass of Chlorella vulgaris