Abstract:Inductively coupled plasma generator is one of the core components of the near-space high-speed target plasma electromagnetic scientific experimental research device, which is often used to simulate high enthalpy and high speed plasma sheath environment. In order to study the discharge characteristics of inductively coupled plasma generator under high power, radio frequency and medium pressure, the numerical simulation and experiment are combined to study its internal heat transfer and flow characteristics in this paper. Based on the local thermodynamic equilibrium conditions, the numerical simulation of large-scale radio frequency and medium pressure inductively coupled plasma with a power of 100–400 kW is carried out through the multi-field coupling of flow, electromagnetic and temperature field, and verified by light intensity and spectrum experiment. The results show that the electromagnetic field distribution in the high-power thermal balance inductively coupled plasma generator is similar to that of the small- and medium-sized power plasma generator. The discharge energy dissipation occurs mainly in the area where the induction coil is located. The temperature of the inner wall of the quartz tube is higher at the coil location than in other areas, and the plasma has a ring-shaped high-temperature structure. The outer wall of the quartz tube is set to be the boundary condition of heat flux for simulating the temperature change of the quartz tube under cold blowing. This setting is in coincidence with factual situations. The wall temperature of the quartz tube at the entrance and at the induction coil section are found to be relatively high. When the large-size inductively coupled plasma generator works, an obvious return vortex is generated at the entrance due to the temperature difference and the electromagnetic pumping effect, and the exit velocity increases slightly with the increase of power. At the same time, the discharge experiment under the corresponding conditions shows that there is found a ring structure with bright edges and dark centers in the axial image of the argon discharge. Moreover, the emission spectrum of argon plasma is measured through the spectrum diagnosis system and the spatial distribution of the generator electron temperature is obtained. The light intensity of the discharge image and the electron temperature measured by the spectrum are found to be in comparative coincidence with the COMSOL simulation temperature result, demonstrating the validity of the numerical simulation results under thermodynamic equilibrium conditions. The numerical simulation results in this paper are also applicable to the optimization design and temperature resistance evaluation of the inductively coupled plasma generator.

3D simulations of the RF wave propagation and power coupling in cold magnetized plasma near an ICRF antenna

Characterization Of Near-Field Coupling Effects From Complicated Three-Dimensional Structures In Rectangular Cavities Using Fast Integral Equation Method

Numerical and Experimental Characterization of RF Waves Propagation in Ion Sources Magnetoplasmas

ANSYS HFSS as a new numerical tool to study wave propagation inside anisotropic magnetized plasmas in the Ion Cylotron Range of Frequencies

Studies on the Plasma-Added Intensification of Gigahertz Radio Frequency Signals

Development of Impedance Sheath Boundary Condition in Stix Finite Element RF Code

RF Simulation and Improvements of an Ion Source Test Facility at HUST

Electromagnetic Fields and Antenna Impedance Analysis of an RF Ion Source at HUST

A model of radiofrequency and plasma coupling for compact ion sources and design

Theoretical Study of the Impedance Matching of the Ferrite Tuner System for ICRF Heating

On the Development of Global Plasma-Ionosphere FDTD Algorithms for Electromagnetic Calculations in the Earth-ionosphere System

Quasi-Two-Dimensional Code for the Calculation of Antenna Impedance of the ICR Heating System

Plasma Simulation and Optimization for a Miniaturized Antenna ECR Ion Source

Finite-difference Time-Domain Studies of Plasma Resonating Structures

Investigation of a parametric instability between ELF and VLF modes driven by antennas immersed in a cold, magnetized plasma

Kinetic simulations of low-pressure inductively coupled plasma: an implicit electromagnetic PIC/MCC model with the ADI-FDTD method

Physical design and recent experimental results of the new ICRF antenna on EAST

3D Thermal-Fluid Coupled Analysis for 81.25 MHz RFQ Accelerator

Numerical Simulation and Experimental Study of High-Power Thermal Equilibrium Inductively Coupled Plasma

Wave modelling in a cylindrical non-uniform helicon discharge

Simulation of beam-induced plasma in gas-filled rf cavities