Abstract:Abstract We investigated pore-scale oil displacement and rock wettability in tertiary low salinity waterflooding (LSW) in a heterogeneous carbonate sample using high-resolution three-dimensional imaging. This enabled the underlying mechanisms of the low salinity effect (LSE) to be observed and quantified in terms of changes in wettability and pore-scale fluid configuration, while also measuring the overall effect on recovery. The results were compared to the behavior under high salinity waterflooding (HSW). To achieve the wetting state found in oil reservoirs, an Estaillades limestone core sample was aged at 11 MPa and 80°C for three weeks. The moderately oil-wet sample was then injected with high salinity brine (HSB) at a range of increasing flow rates, namely at 1, 2, 4, 11, 22 and 42 μL/min with 10 pore volumes injected at each rate. Subsequently, low salinity brine (LSB) was injected following the same procedure. X-ray micro-computed tomography (micro-CT) was used to visualize the fluid configuration in the pore space. A total of eight micro-CT images, with a resolution of 2.3 μm/voxel, were acquired after both low salinity and high salinity floods. These high-resolution images were used to monitor fluid configuration in the pore space and obtain fluid saturations and occupancy maps. Wettability was characterized by measurements of in situ contact angles and curvatures. The results show that the pore-scale mechanisms of improved recovery in LSW are consistent with the development of water micro-droplets within the oil and the expansion of thin water films between the oil and rock surface. Before waterflooding and during HSW, the measured contact angles were constant and above 110o, while the mean curvature and the capillary pressure values remained negative, suggesting that the HSB did not change the wettability state of the rock. However, with LSW the capillary pressure increased towards positive values as the wettability shifted towards a mixed-wet state. The fluid occupancy analysis reveals a salinity-induced change in fluid configuration in the pore space. HSB invaded mainly the larger pores and throats, but with LSW brine invaded small-size pores and throats. Overall, our analysis shows that a change from a weakly oil-wet towards a mixed-wet state was observed mainly after LSW, leading to an incremental increase in oil recovery. This work established a combined coreflooding and imaging methodology to investigate pore-scale mechanisms and wettability alteration for tertiary LSW in carbonates. It improves our understanding of LSW as an enhanced oil recovery (EOR) method for potential field-scale applications. The data provides a valuable benchmark for pore-scale modelling as well as an insight into how even modest wettability changes can lead to additional oil recovery.

A Review of Wettability Alteration by Spontaneous Imbibition Using Low Salinity Water in Naturally Fractured Reservoirs

Microfluidics experimental investigation of the mechanisms of enhanced oil recovery by low salinity water flooding in fractured porous media

Mechanisms of fracturing fluid spontaneous imbibition behavior in shale reservoir: A review

Wettability Alteration and Enhanced Oil Recovery in Carbonate Porous Media by Tuning Waterflood Chemistry

Pore-Scale Imaging of Controlled-Salinity Waterflooding in a Heterogeneous Carbonate Rock at Reservoir Conditions

Enhanced Oil Recovery from a Carbonate Reservoir During Low Salinity Water Flooding: Spontaneous Imbibition and Core-Flood Methods

A Semi-Analytical Solution for Countercurrent Spontaneous Imbibition in Water-Wet Fractured Reservoirs

Review of Low Salinity Waterflooding Mechanisms: Wettability Alteration and Its Impact on Oil Recovery

Experimental study of surfactant-enhanced spontaneous imbibition in fractured tight sandstone reservoirs: The effect of fracture distribution

Experimental Research on Behavior of Spontaneous Imbibition and Displacement After Fracturing in Terrestrial Shale Oil Based on Nuclear Magnetic Resonance Measurements

Pore-Scale Imaging of Tertiary Low Salinity Waterflooding in a Heterogeneous Carbonate Rock at Reservoir Conditions

Pore-scale simulation of low-salinity waterflooding in mixed-wet systems: effect of corner flow, surface heterogeneity and kinetics of wettability alteration

Application of Low-Salinity Waterflooding in Heavy Oil Sandstone Reservoir: Oil Recovery Efficiency and Mechanistic Study

Phase Behavior, Wettability Alteration, and Oil Recovery of Low-Salinity Surfactant Solutions in Carbonate Reservoirs

Pore-scale study of counter-current imbibition in strongly water-wet fractured porous media using lattice Boltzmann method

Enhanced Oil Recovery by Low-Salinity Water Spontaneous Imbibition (LSW-SI) in a Typical Tight Sandstone Formation of Mahu Sag from Core Scale to Field Scale

Pore-scale investigation of low-salinity water flooding in a heterogeneous-wet porous medium

From Atoms to Pre-salt Reservoirs: Multiscale Simulations of the Low-Salinity Enhanced Oil Recovery Mechanisms

Quantitative characterization of imbibition in fractured porous media based on fractal theory

Modelling of Carbonate Rock Wettability Based on Surface Charge and Calcite Dissolution

A short review of recent studies on applying low salinity water injection in unconventional reservoirs: An experimental approach