Pore-Scale Imaging of Tertiary Low Salinity Waterflooding in a Heterogeneous Carbonate Rock at Reservoir Conditions

Ahmed M. Selem,Nicolas Agenet,Martin J. Blunt,Branko Bijeljic

DOI: https://doi.org/10.2118/206357-ms

2021-09-15

Abstract:Abstract We investigated pore-scale oil displacement and rock wettability in tertiary low salinity waterflooding (LSW) in a heterogeneous carbonate sample using high-resolution three-dimensional imaging. This enabled the underlying mechanisms of the low salinity effect (LSE) to be observed and quantified in terms of changes in wettability and pore-scale fluid configuration, while also measuring the overall effect on recovery. The results were compared to the behavior under high salinity waterflooding (HSW). To achieve the wetting state found in oil reservoirs, an Estaillades limestone core sample was aged at 11 MPa and 80°C for three weeks. The moderately oil-wet sample was then injected with high salinity brine (HSB) at a range of increasing flow rates, namely at 1, 2, 4, 11, 22 and 42 μL/min with 10 pore volumes injected at each rate. Subsequently, low salinity brine (LSB) was injected following the same procedure. X-ray micro-computed tomography (micro-CT) was used to visualize the fluid configuration in the pore space. A total of eight micro-CT images, with a resolution of 2.3 μm/voxel, were acquired after both low salinity and high salinity floods. These high-resolution images were used to monitor fluid configuration in the pore space and obtain fluid saturations and occupancy maps. Wettability was characterized by measurements of in situ contact angles and curvatures. The results show that the pore-scale mechanisms of improved recovery in LSW are consistent with the development of water micro-droplets within the oil and the expansion of thin water films between the oil and rock surface. Before waterflooding and during HSW, the measured contact angles were constant and above 110o, while the mean curvature and the capillary pressure values remained negative, suggesting that the HSB did not change the wettability state of the rock. However, with LSW the capillary pressure increased towards positive values as the wettability shifted towards a mixed-wet state. The fluid occupancy analysis reveals a salinity-induced change in fluid configuration in the pore space. HSB invaded mainly the larger pores and throats, but with LSW brine invaded small-size pores and throats. Overall, our analysis shows that a change from a weakly oil-wet towards a mixed-wet state was observed mainly after LSW, leading to an incremental increase in oil recovery. This work established a combined coreflooding and imaging methodology to investigate pore-scale mechanisms and wettability alteration for tertiary LSW in carbonates. It improves our understanding of LSW as an enhanced oil recovery (EOR) method for potential field-scale applications. The data provides a valuable benchmark for pore-scale modelling as well as an insight into how even modest wettability changes can lead to additional oil recovery.