Abstract:Abstract We investigated pore-scale oil displacement and rock wettability in tertiary low salinity waterflooding (LSW) in a heterogeneous carbonate sample using high-resolution three-dimensional imaging. This enabled the underlying mechanisms of the low salinity effect (LSE) to be observed and quantified in terms of changes in wettability and pore-scale fluid configuration, while also measuring the overall effect on recovery. The results were compared to the behavior under high salinity waterflooding (HSW). To achieve the wetting state found in oil reservoirs, an Estaillades limestone core sample was aged at 11 MPa and 80°C for three weeks. The moderately oil-wet sample was then injected with high salinity brine (HSB) at a range of increasing flow rates, namely at 1, 2, 4, 11, 22 and 42 μL/min with 10 pore volumes injected at each rate. Subsequently, low salinity brine (LSB) was injected following the same procedure. X-ray micro-computed tomography (micro-CT) was used to visualize the fluid configuration in the pore space. A total of eight micro-CT images, with a resolution of 2.3 μm/voxel, were acquired after both low salinity and high salinity floods. These high-resolution images were used to monitor fluid configuration in the pore space and obtain fluid saturations and occupancy maps. Wettability was characterized by measurements of in situ contact angles and curvatures. The results show that the pore-scale mechanisms of improved recovery in LSW are consistent with the development of water micro-droplets within the oil and the expansion of thin water films between the oil and rock surface. Before waterflooding and during HSW, the measured contact angles were constant and above 110o, while the mean curvature and the capillary pressure values remained negative, suggesting that the HSB did not change the wettability state of the rock. However, with LSW the capillary pressure increased towards positive values as the wettability shifted towards a mixed-wet state. The fluid occupancy analysis reveals a salinity-induced change in fluid configuration in the pore space. HSB invaded mainly the larger pores and throats, but with LSW brine invaded small-size pores and throats. Overall, our analysis shows that a change from a weakly oil-wet towards a mixed-wet state was observed mainly after LSW, leading to an incremental increase in oil recovery. This work established a combined coreflooding and imaging methodology to investigate pore-scale mechanisms and wettability alteration for tertiary LSW in carbonates. It improves our understanding of LSW as an enhanced oil recovery (EOR) method for potential field-scale applications. The data provides a valuable benchmark for pore-scale modelling as well as an insight into how even modest wettability changes can lead to additional oil recovery.

Investigation on the micro-flow mechanism of enhanced oil recovery by low-salinity water flooding in carbonate reservoir

Pore-Scale Imaging of Controlled-Salinity Waterflooding in a Heterogeneous Carbonate Rock at Reservoir Conditions

Insights into mechanism of low salinity water flooding in sandstone reservoir from interfacial features of oil/brine/rock via intermolecular forces

Pore-Scale Imaging of Tertiary Low Salinity Waterflooding in a Heterogeneous Carbonate Rock at Reservoir Conditions

Application of Low-Salinity Waterflooding in Heavy Oil Sandstone Reservoir: Oil Recovery Efficiency and Mechanistic Study

Enhanced Oil Recovery from a Carbonate Reservoir During Low Salinity Water Flooding: Spontaneous Imbibition and Core-Flood Methods

Review of Low Salinity Waterflooding Mechanisms: Wettability Alteration and Its Impact on Oil Recovery

Experimental Investigation on the Pore-Scale Mechanism of Improved Sweep Efficiency by Low-Salinity Water Flooding Using a Reservoir-on-a-Chip

Macroscale Modeling of Geochemistry Influence on Polymer and Low-Salinity Waterflooding in Carbonate Oil Reservoirs

Experimental study on CO2/Water flooding mechanism and oil recovery in ultralow - Permeability sandstone with online LF-NMR

Microfluidics experimental investigation of the mechanisms of enhanced oil recovery by low salinity water flooding in fractured porous media

Effect of Electrokinetics and Thermodynamic Equilibrium on Low-Salinity Water Flooding for Enhanced Oil Recovery in Sandstone Reservoirs

Impact of rock morphology on the dominating enhanced oil recovery mechanisms by low salinity water flooding in carbonate rocks

Wettability Alteration and Enhanced Oil Recovery in Carbonate Porous Media by Tuning Waterflood Chemistry

Integrated Geochemical Modelling of Low Salinity Waterflooding for Enhanced Oil Recovery in Carbonate Reservoir

Numerical modeling and experimental investigation on the effect of low-salinity water flooding for enhanced oil recovery in carbonate reservoirs

A comprehensive insight on the impact of individual ions on Engineered Waterflood: With already strongly water-wet sandstone

Detecting pH and Ca2+ increase during low salinity waterflooding in carbonate reservoirs: Implications for wettability alteration process

From Atoms to Pre-salt Reservoirs: Multiscale Simulations of the Low-Salinity Enhanced Oil Recovery Mechanisms

Critical Assessment of the Hybrid Impact of Surfactants on Modified Salinity Water Flooding

Investigation of modified Water chemistry for improved oil recovery: Application of DLVO theory and surface complexation model