Abstract:Biodiesel is a renewable source of energy that has the potential to replace fossil fuel-based resources. It is produced via the transesterification reaction in which a triglyceride reacts with methanol in the presence of a catalyst. Cosolvents are usually added to the reactants in transesterification to improve the mutual solubility of methanol and triglycerides and to create a single phase. The commonly used cosolvents in transesterification include tetrahydrofuran (THF) and diethyl ether (DEE). Understanding the thermodynamic properties of this system is important in the selection of cosolvent. In this study, molecular dynamics simulations were used to study the mixing behavior between the components of ternary mixtures of triolein/methanol/THF and triolein/methanol/DEE via the application of Flory-Huggins theory of solutions. A simple approach to calculation of the Flory-Huggins interaction parameters is used in which the mixing energy is derived from averaged non-bonded pair interaction energies. Apart from pure triolein, these ternary systems resemble the experimentally studied ternary systems employing various plant-based oils. The binary interaction parameters, Gibbs Free energy and chemical potentials of the components were calculated to study the mixing behavior. Our results show that along the experimental phase boundary the binary interaction parameters remain relatively unchanged with a deviation observed at the highest volume fractions of triolein where the highest binary interactions were observed indicating the possibility of phase separation. The Gibbs energy of mixing for the systems changed from positive to negative as one moves from two phase to single phase part of the ternary system as expected and in agreement with experimental data. The chemical potentials of the ternary mixture components were calculated from the partial derivatives of the Gibbs free energy of mixing. The activities calculated from Flory-Huggins chemical potentials were compared to those calculated using the UNIFAC model. There is good agreement between the two, with both able to predict a single and biphasic mixture. However, disagreements are noted at low and high concentrations of triolein.

One-phase Transesterification of Palm Oil in to Biodiesel with Co-solvent Methyl Esters: The Effect of Adding Co-solvent to Kinetic Energy and Dipole Moment

Phase Composition in the Process of Biodiesel Preparation from Palm Oil and the Properties of Biodiesel

Co-solvents transesterification of cotton seed oil into biodiesel: Effects of reaction conditions on quality of fatty acids methyl esters

Esterification of High-Acid Value Oil

Biodiesel production process without glycerol by-product with base catalyst: effect of reaction time and type of catalyst on kinetic energy and solubility

Solubility of Multicomponent Systems in the Biodiesel Production by Transesterification of Jatropha Curcas L. Oil with Methanol

CO-SOLVENT TETRAHYDROFURAN IN THE PRODUCTION OF BIODIESEL FROM USED COOKING OIL USING THE TRANSESTERIFICATION METHOD

Highly efficient procedure for the transesterification of vegetable oil

Optimization of Methyl Ester Through Simultaneous Esterification –Transesterification Reactions Using Waste Cooking Oil as Raw Material

Transesterification of palm oil into biodiesel using ChOH ionic liquid in a microwave heated continuous flow reactor

Glycerol Esterification of Free Fatty Acids Catalyzed by Zinc Glycerolate for Biodiesel Production from Acidified Palm Oil: Optimization, Kinetic Study, and Process Evaluation

Transesterification of Palm Oil with Methanol to Biodiesel over a KF/Hydrotalcite Solid Catalyst

Ultrafiltration of Triglyceride from Biodiesel Using the Phase Diagram of Oil–fame–meoh

Effect of fatty acid methyl ester on the mass transfer and rate of an acid transesterification reaction

Molecular dynamics study of the thermodynamic properties of triglyceride/methanol mixtures in the presence of cosolvent

Synthesis of Biodiesel from Palm Oil by Transesterification on Supported Solid Base Catalysts

Heterogeneization of Biodiesel Production by Simultaneous Esterification and Transesterification of Oleins

Liquid–Liquid Equilibrium of Sesame Fatty Acid (Ethyl and Methyl) Ester + Glycerol + Ethanol/Methanol Mixtures at Different Temperatures

Characterization of homogenous acid catalyzed biodiesel production from palm oil: experimental investigation and numerical simulation

Synthesis of biodiesel from palm oil by transesterification on solid base catalysts

Improvement in lipase-catalyzed methanolysis of triacylglycerols for biodiesel production using a solvent engineering method