Abstract:Microalgae have emerged as a promising source of biomass to produce renewable biofuels due to their ability to synthesize high-energy density compounds of commercial interest. This study proposes an approach for pilot-scale oil extraction, purification by fractional distillation, hydrocarbon characterization by gas chromatography coupled to mass spectrometry (GC-MS), evaluation of physicochemical parameters of the produced hydrocarbons, preliminary cost analysis, and challenges and future opportunities for green diesel on a commercial scale. Here, the microalgae Tetradesmus obliquus was cultivated in 12 m³ photobioreactors using biodigested swine waste as a culture medium. The resulting biomass was subjected to drying and harvesting, followed by oil extraction using a hot solvent extraction method, followed by distillation to purify the compounds. Three different extraction and distillation experiments were conducted, each using different solvent combinations. The results obtained revealed that extraction with a solvent blend, composed of hexane and ethanol, provided more significant yields compared to extraction with pure hexane. GC-MS analysis showed the presence of alkanes and alkenes in the oil samples, and the proportion of solvent used in the extraction directly influenced the production of alkanes. Additionally, specific hydrocarbons such as 4-methyl-1-decene, 8-heptadecene, 1-pentadecene, 9-heneicosene, and 2-dodecene were identified. The evaluation of the physicochemical parameters demonstrated that the calorific value of the distilled oil samples is within the range of typical values for petroleum diesel. However, it was observed that the distilled oil samples had higher sulfur content compared to conventional diesel. Regarding the cost analysis, it was found that it varies depending on the experimental conditions. In particular, the process using a solvent mixture of 70% hexane and 30% ethanol proved to be more economical than the others, since it extracted a greater quantity of oil with a lower initial biomass requirement. In summary, this microalgae-derived hydrocarbon production process is promising and offers insights for compound purification and future biofuel applications.

Soxhlet Extraction of Spirogyra sp. as an Energy Source and Physicochemical Characterization of Produced Biodiesel

Subcritical water extraction of lipids from wet algae for biodiesel production

In Situ Ethyl Ester Production from Wet Algal Biomass under Microwave-Mediated Supercritical Ethanol Conditions

Enzymatic Ethanolysis Subjected to Schizochytrium Biomass: Sequential Processing for DHA Enrichment and Biodiesel Production

Optimizing Algal Oil Extraction and Transesterification Parameters through RSM, PCA, and MRA for Sustainable Biodiesel Production

A novel rapid ultrasonication-microwave treatment for total lipid extraction from wet oleaginous yeast biomass for sustainable biodiesel production

Orthogonal Optimization Of A Newly Isolated Microalga Desmodesmus Sp.-Chx1 As A Potential Candidate For Biodiesel Production

Optimization of Oil Yield from the Macro Algae Spirogyra by Solvent Extraction Process Using RSM and ANN

Potential of Algal Biomass and Their Cultivation for Biofuels Production as Plausible Bio-resource for Economic Sustainability

STUDY ON PREPARATION OF BIODIESEL FROM MICROALGAL OIL

Efficient Biodiesel Conversion From Microalgae Oil Of Schizochytrium Sp.

Optimization of Cultivation Conditions of Native Microalga Scenedesmus quadricauda and Evaluation of Lipids for Enhanced Biodiesel Production

Production of a sustainable fuel from microalgae Chlorella minutissima grown in a 1500 L open raceway ponds

Maximizing Lipid Extraction from Chlorella pyrenoidosa: A Study on the Effectiveness of Cell Disruption Techniques

Characterisation of bio-oil extracted from microalgae Botryococcus sp. biomass grown in domestic and food processing wastewaters for valuable hydrocarbon production

Microalgal synthesis of the biodiesel employing simultaneous extraction and esterification via heterogeneous catalyst

Unlocking pilot-scale green diesel production from microalgae

Rapid extraction of lipid from wet microalgae biomass by a novel buoyant beads and ultrasound assisted solvent extraction method

Lipids of Rhodotorula mucilaginosa IIPL32 with biodiesel potential: Oil yield, fatty acid profile, fuel properties

Microalgae biodiesel: Current status and future needs for engine performance and emissions

Enzymatic Transesterification of Yeast Oil for Biodiesel Fuel Production