Abstract:Open path Fourier transform infrared (OP-FTIR) spectroscopy is a new air monitoring technique that can be used to measure concentrations of air contaminants in real or near-real time. OP-FTIR spectroscopy has been used to monitor workplace gas and vapor exposures, emissions from hazardous waste sites, and to track emissions along fence lines. This paper discusses a statistical process control technique that can be used with air monitoring data collected with an OP-FTIR spectrometer to detect departures from normal operating conditions in the workplace or along a fence line. Time series data, produced by plotting consecutive air sample concentrations in time, were analyzed. Autocorrelation in the time series data was removed by fitting dynamic models. Control charts were used with the residuals of the model fit data to determine if departures from defined normal operating conditions could be rapidly detected. Shewhart and exponentially weighted moving average (EWMA) control charts were evaluated for use with data collected under different room air flow and mixing conditions. Under rapidly changing conditions the Shewhart control chart was able to detect a leak in a simulated process area. The EWMA control chart was found to be more sensitive to drifts and slowly changing concentrations in air monitoring data. The time series and statistical process control techniques were also applied to data obtained during a field study at a chemical plant. A production area of an acrylonitrile, 1,3-butadiene, and styrene (ABS) polymer process was monitored in near-real time. Decision logics based on the time series and statistical process control technique introduced suggest several applications in workplace and environmental monitoring. These applications might include signaling of an alarm or warning, increasing levels of worker respiratory protection, or evacuation of a community, when gas and vapor concentrations are determined to be out-of-control.

Real-World Application of Open-Path UV-DOAS, TDL, and FT-IR Spectroscopy for Air Quality Monitoring at Industrial Facilities

Applications of Online UV-Vis Spectrophotometer for Drinking Water Quality Monitoring and Process Control: A Review

Application of Long Open Path Ftir System in Ambient Air Monitoring

Workplace and environmental air contaminant concentrations measured by open path Fourier transform infrared spectroscopy: a statistical process control technique to detect changes from normal operating conditions

Challenges associated with the atmospheric monitoring of areal emission sources and the need for optical remote sensing techniques—an open-path Fourier transform infrared (OP-FTIR) spectroscopy experience report

[Open-path online monitoring of ambient atmospheric CO2 based on laser absorption spectrum]

Simultaneous Measurement of SO 2 and NO 2 Concentration Using an Optical Fiber-Based LP-DOAS System

Industrial Air Pollution Monitoring by Active and Passive Fourier Transform Infrared Spectroscopy

[Advanced Development of Remote Sensing FTIR in Air Environment Monitoring].

Experimental Study on a New Spectrometry Technique for Emission Monitoring

Open-Path Detection of Organic Vapors via Quantum Infrared Spectroscopy

Comparative study to evaluate three ground-based optical remote sensing techniques under field conditions by a gas tracer experiment

An On-Line Monitoring Technique for Trace Gases in Atmosphere Based on Differential Optical Absorption Spectroscopy

Atmospheric and Environmental Sensing by Photonic Absorption Spectroscopy

Study on Scanning Differential Optical Absorption Spectroscopy for Monitoring Vertical Profiles of Atmospheric Pollutant

Performance of Open-Path Lasers and Fourier Transform Infrared Spectroscopic Systems in Agriculture Emissions Research

Performance of open-path lasers and FTIR spectroscopic systems

High Sensitivity real-time VOCs monitoring in air through FTIR Spectroscopy using a Multipass Gas Cell Setup

Real-time Data Processing of Remote Measurement of Air Pollution by Infrared Passive Scanning Imaging System

Open-path Dual-comb Spectroscopy for Multispecies Trace Gas Detection in the 4.5 μm to 5 μm Spectral Region

A new type UV-visible DOAS system based on photodiode array (PDA)