Abstract:The thermal sensitive cotton-g-PNIPAAm was prepared through free radical grafting reaction initiated by different initiators including ammonium ceric nitrate (CAN), potassium persulfate (KPS) and hydrogen peroxide/ascorbic acid (H2O2/H(2)A system). The degrees of grafting (G) achieved by different initiators could be sorted into descent order as following: G (H2O2/H(2)A) > G (KPS) > G (CAN). The other factors affecting the degree of grafting, such as the concentration of initiator, reaction time, temperature and the concentration of monomer, were studied. The results showed that the optimal conditions for grafting reaction using H2O2/H(2)A initiating system were: initiator dosage 7.5 mmol/L mole ration of H2O2 to H(2)A = 1 : 0.6), reaction time 1.5 h, monomer concentration 5% similar to 15% and the reaction temperature 25 degrees C. FTIR spectrogram of grafted cotton fiber showed characteristic absorptions of -CH3, C=O, -N-H, -C-N and -CH(CH3)(2) groups at 2967.5, 2857.4, 1623.9, 1540.3, 1457.4 cm(-1), 1385.6 and 1365.4 cm(-1) giving the evidence for the successful grafting of PNIPAAm onto cotton fiber surface. The extraneous polymer attached to fiber surface can be observed in SEM images of grafted cotton samples. DSC analysis revealed that all grafted cotton fibers had the LCST around 32 similar to 33 degrees C which was very close to the LCST of pure PNIPAAm gel (32.48 degrees C). The raising of grafting degree has little impact on LCST but increases the reversible enthalpy change (Delta H) of the cotton-g-PNIPAAm. In the falling-drop test (AATCC 79) and capillary rise test (FZ/T01071), the fabric samples of cotton-g-PNIPAAm demonstrated different water absorbing abilities at different temperatures which meant that the cotton fiber had been endowed with thermo sensibility by PNIPAAm grafting. A grafting degree between 25% similar to 45% is suitable for creating high thermo sensitivity. Other grafting degrees out of above range were not suggested. The analysis and discussion about the relationship between Delta H and swelling/shrinking time of cotton-g-PNIPAAm indicated that cotton-g-PNIPAAm reacted to temperature much quickly than pure PNIPAAm gel.

Grafting of Acrylamide to Loomstate Cotton Fabric Using Potassium Permanganate-Thiourea Redox System

Influence of Small Amount of Co-Monomers on Acrylonitrile Polymerization in Dimethylformamide (DMF) Solution

THE SYNTHESIS AND CHARACTERIZATION OF STARCH-DMDAAC-AM GRAFT COPOLYMER

Grafting of cotton fabrics with diallyldimethylammonium chloride

Grafting Polymerization of Acrylic Acid Onto Preirradiated Polypropylene Fabric

STUDY ON PRE-IRRADIATION GRAFTING OF NIPAAm ONTO COTTON CELLULOSE FABRIC

Pre-irradiation Grafting of Temperature Sensitive Hydrogel on Cotton Cellulose Fabric

Structural Modification of Starch Nanoparticles Via Graft Copolymerization Using KMnO4, HClO4 and HNO3 Redox Pair

Preparation of Pnipaam Grafted Cotton and Its Thermal Sensitivity

Radiation Grafting Of Binary Monomers Onto Cotton Cellulose

GRAFT POLYMERIZATION OF AN OXAZOLIDINONYL-CONTAINING ACRYLIC MONOMER ON CELLULOSE FIBERS

Effect of KMnO4 on chemical, crystal and microscopic structure of polyacrylonitrile fibers

KINETICS OF ACRYLAMIDE POLYMERIZATION IN POLYETHYLENE GLYCOL AQUEOUS SOLUTIONS

Synthesis, metrological characterization, and dyeing properties of surface grafted viscose fabric using peroxydisulfate/ferrous II ions redox pair

Technological Evaluation of Methacrylic Acid/Fenugreek Gum Grafted Products as Thickener in Textile Printing

Graft Copolymerization of Methyl Methacrylate Onto Hydoxyl-Propyl-Methyl Cellulose Initiated by KMnO_4-Oxalic Acid Redox System

Graft Copolymerization of Methyl Acrylate Onto Potato Starch Initiated by Ceric Ammonium Nitrate

Sodium Salt of Partially Carboxymethylated Sodium Alginate-g-Poly(acrylonitrile): I. Photo-Induced Synthesis, Characterization, and Alkaline Hydrolysis

Application of polyethylenimine hyperbranched polymers in low salt reactive dyeing of cellulose

In-situ polymerization, colorization, and functionalization of amino-modified cotton fabrics with Catechol via horseradish peroxidase-hydrogen peroxide system

Oxidation and TD-DFT of Toxic Acriflavine Hydrochloride Dye by Potassium Permanganate in Neutral Media: Kinetics and Removal of Dyes from Wastewater