Abstract:BackgroundPig manure utilization and valorization is an important topic with tightening regulations focused on ecological and safety issues. By itself pig manure is a poor substrate for biogas production because of its excessive nitrogen content relative to available organic carbon. Such substrate is alkaline, and methanogenesis can be suppressed, and so additional substrates with high organic carbon must be added. The most promising is straw, which is available from adjacent biogas plant cultures. However, the abundant lignocellulosic biomass of wheat straw undergoes slow decomposition, and only a fraction of the chemical energy can be converted into biogas; thus economical methods for pretreatment increasing bioavailability are sought.ResultsA method was investigated to increase the methane yield in a full-scale plant for co-fermenting pig manure with corn silage, which was the default substrate in the original source reactors. Increased lignocellulosic bioavailability of wheat straw was achieved by combining liquid hot water (LHW) and steam explosion (SE). According to FT-IR analysis, the treatment resulted in hemicellulose hydrolysis, partial cellulose depolymerization, and lignin bond destruction. Low-mass polysaccharides (0.6 × 103 g mol−1) had significantly higher concentration in the leachate of LHW-SE wheat straw than raw wheat straw. The methanogenic potential was evaluated using inoculum from two different biogas plants to study the influence of microorganism consortia. The yield was 24–34% higher after the pretreatment process. In a full-scale biogas plant, the optimal conditions were ~ 165 °C, ~ 2.33 MPa, and 10 min in LHW and ~ 65 °C and ~ 0.1 MPa for SE. The processes did not generate detectable inhibitors according to GC–MS analysis, such as furfural and 5-hydroxymethylfurfural.ConclusionsThe LHW-SE combined pretreatment process increases the bioavailability of carbohydrates from wheat straw. The LHW-SE treated wheat straw gave similar biogas yields to corn silage, thus enables at least partial replacement of corn silage and is good for diversification of substrates. Surprisingly, microorganisms consortia from other biogas plant fed with other substrates may have higher efficiency in utilization of tested substrate. Thus, methanogenic consortia may be considered in the process of optimization at industrial scale. The efficiency was calculated, and the LHW-SE may be profitable at full industrial scale and further optimization is proposed.

Sustainable green biogas production from pretreated wheat straw blended with coffee husk using neem leaves-based iron (III) nanocatalyst via response surface methodology

Assessment of the Impact of Pretreatment of Spent Coffee Grounds with Diluted Sulfuric Acid on the Efficiency of Methane and Lactic Acid Fermentation

Sorghum stover and winery solid wastes co-digestion: application of iron oxide nanoparticles for biogas yield optimisation

Bio-methane Generation from Anaerobic Co-digestion of Eichhornia (Water Hyacinth) and Kitchen Edible Material Ravage and Waste Paper with Pond Sludge and Cow Compost by Using Chemical Pretreatment

Optimization of the Biomethane Production Process by Anaerobic Digestion of Wheat Straw Using Chemical Pretreatments Coupled with Ultrasonic Disintegration

Application of nanomaterials in anaerobic digestion processes: A new strategy towards sustainable methane production

Nanobiocatalysts for efficient conversion of microwave aided ionic liquid pretreated rice straw biomass to biofuel

Optimization of biogas production from straw wastes by different pretreatments: Progress, challenges, and prospects

Stimulating Methane Production from Poultry Manure Digest with Sewage Sludge and Organic Waste by Thermal Pretreatment and Adding Iron or Sodium Hydroxide

ENHANCEMENT OF BIOGAS PRODUCTION FROM ANAEROBIC CO-DIGESTION OF WASTEWATER SLUDGE, KITCHEN WASTE AND MANURE

Iron-Based Additives and Biogas Production from Organic Wastes Using Anaerobic Digestion Process

Enhancing methane production from food waste with iron-carbon micro-electrolysis in a two-stage process

Application of green synthetic iron oxide nanocatalyst in biohydrogen production from domestic wastewater

Enhancing biogas plant production using pig manure and corn silage by adding wheat straw processed with liquid hot water and steam explosion

Improved biomethanation of horse manure through acid-thermal pretreatment and supplementation of iron nanoparticles under mesophilic and thermophilic conditions

Processes of Metal Oxides Catalyst on Conversion of Spent Coffee Grounds into Rich-Synthesis Gas by Gasification

Enhancing methane production of synthetic brewery water with granular activated carbon modified with nanoscale zero-valent iron (NZVI) in anaerobic system

Improvement of biohydrogen production from rice straw hydrolysate by green-self-prepared nano-silica

Study on the remediation of groundwater nitrate pollution by pretreated wheat straw and woodchips

Intensified wheat husk conversion employing energy-efficient hybrid electromagnetic radiations for production of fermentable sugar: process optimization and life cycle assessment

Impact of Nanoscale Magnetite and Zero Valent Iron on the Batch-Wise Anaerobic Co-Digestion of Food Waste and Waste-Activated Sludge