Abstract:Abstract Background A regular supply of nutrients such as nitrogen and phosphorus to agriculture is needed for global food security, and increased recycling of nutrients back to agriculture from organic waste streams is necessary for increased rural–urban sustainability. Anaerobic digestion of sewage sludge and agricultural wastes is widely applied to stabilize the substrate and capture some of its energetic value via biogas production. Anaerobic digestate is a concentrated source of nutrients to which nutrient recovery technologies can be applied. By combining anaerobic digestion and nutrient recovery technologies on the digestate, both energy and nutrient recovery can be achieved. Two promising technologies that could increase nutrient recycling from different types of wastewater are struvite precipitation and ammonia stripping. This review examined the effectiveness of these ecotechnologies for the recovery of nitrogen and phosphorus from anaerobic digestate with the aim of reducing the impact of waste on the environment. Methods We searched for academic and grey literature published after 2013. Searches were performed in 5 bibliographic databases in English, in the search engine Google Scholar in English, Swedish, Finnish and Polish, and across a range of organisational websites in English, Swedish, Finnish and Polish. Eligibility screening was conducted at two levels: ‘title and abstract’ and ‘full text’. Included eligible studies were subject to a critical appraisal that assessed external and internal study validity. We extracted information on study characteristics, intervention, comparators, effect modifiers, and measured outcomes. Data synthesis included narrative synthesis of each study of sufficient validity. We performed quantitative synthesis on a subset of studies. Review findings The review included 30 studies on struvite precipitation and 8 studies on ammonia stripping. Both pH and Mg:PO 4 ratio were found to have a clear influence on the effectiveness of struvite precipitation process (and thus nutrient removal rates). The response to pH was found to be non-linear, resembling a bell curve with a maximum around pH 9.5. Mg:PO 4 ratio was found to have a positive effect on removal up to a ratio as high as 4:1. However, it should be noted that high removal efficiencies were sometimes achieved at a ratio as low as 1:1 as well. Although the effects of pH and Mg:PO 4 ratio were clear, the model developed could not accurately predict removal based on these two parameters alone. Studies on ammonia stripping were relatively heterogeneous. Due to the small size of the evidence base, and the heterogeneity between studies, no conclusions are presented regarding the influence of different process parameters on the outcome of ammonia stripping. Conclusions In conclusion, when performed under the right conditions (i.e. pH around 9.5 and Mg:PO 4 ratio of at least 1:1), available evidence suggests that struvite precipitation is an effective technology for the recovery of nutrients from the liquid phase of anaerobic digestate. The evidence base is limited for ammonia stripping. We provided suggestions of which data to report in future studies.

Nutrient recovery through struvite precipitation from anaerobically digested poultry wastewater in an air-lift electrolytic reactor: Process modeling and cost analysis

Enhanced nutrient recovery from anaerobically digested poultry wastewater through struvite precipitation by organic acid pre-treatment and seeding in a bubble column electrolytic reactor

Phosphorus removal and recovery from wastewater by highly efficient struvite crystallization in an improved fluidized bed reactor

Nutrient Recovery From Organic-Rich Wastewater Through Struvite Precipitation using Air Cathode Electrocoagulation Technology

Struvite precipitation from biogas digestion slurry using a two-chamber electrolysis cell with a magnesium anode

Prospective Life Cycle Assessment and Cost Analysis of Novel Electrochemical Struvite Recovery in a U.S. Wastewater Treatment Plant

Study on Removal of Phosphorus As Struvite from Synthetic Wastewater Using a Pilot-Scale Electrodialysis System with Magnesium Anode.

Phosphate Recovery from Swine Wastewater by a Struvite Precipitation Electrolyzer

Effective recovery of struvite from wastewater by electrochemical process

Ammonium and Phosphate Recovery in a Three Chambered Microbial Electrolysis Cell: Towards Obtaining Struvite from Livestock Manure

Electrified Nutrient Recovery at Municipal Wastewater Facilities: Sampling, Screening and Multivariate Analyses

Electrochemical Recovery of Phosphorus from Simulated and Real Wastewater: Effect of Investigational Conditions on the Process Efficiency

Nitrogen and phosphorus recovery as struvite from nutrient rich wastewater using electrochemical method: A review

Effectiveness of struvite precipitation and ammonia stripping for recovery of phosphorus and nitrogen from anaerobic digestate: a systematic review

Electrochemical Recovery of N and P from Municipal Wastewater

Recovery of ammonia through struvite production using anaerobic digestate of piggery wastewater and leachate of sewage sludge ash

Phosphate recovery from swine wastewater using plant ash in chemical crystallization

Simultaneous Recovery of Ammonium and Phosphorus Via the Integration of Electrodialysis with Struvite Reactor

Recovering nutrients and unblocking the cake layer of an electrochemical anaerobic membrane bioreactor

Reagent-free phosphorus precipitation from a denitrified swine effluent in a batch electrochemical system

Nutrients removal and recovery from anaerobically digested swine wastewater by struvite crystallization without chemical additions