Abstract:This paper reports a microfluidic viscometer based on electrofluidic circuits for measuring viscosities of liquid samples. The developed micro-device consists of a polydimethylsiloxane (PDMS) layer for electrofluidic circuits, a thin PDMS membrane, another PDMS layer for sample pretreatment, and a glass substrate. As the sample flows inside the microfluidic channel, its viscosity causes flow resistance and a pressure drop along this channel. This pressure drop, in turn, generates a hydraulic pressure which deforms the PDMS membrane, causing changes in the cross-sectional area and the electrical resistance of the electrofluidic resistor. This small resistance change is then measured via the electrofluidic Wheatstone bridge to relate the measured voltage difference to the fluidic viscosity. The performance of this viscometer was first tested by flowing nitrogen gas with controllable pressures into the device. The relationship between measured voltage difference and input gas pressure was analyzed to be linear in the pressure range of 0–15 psi. Another test using pure water indicated good linearity between measured voltage difference and flow rate in the rate range of 20–100 μL/min. Viscosities of glycerol/water solutions with volume/volume (v/v) concentrations ranging from 0 to 30% were measured, and these values were close to those obtained using commercially available viscometers. In addition, the sample-pretreatment layer can be used to mix and/or dilute liquid samples to desired concentrations. Therefore, this microfluidic device has potential for measurements of fluidic viscosity in a fast, accurate, and high-throughput manner.

Method of the viscosity measurement by means of the vibrating micro-/nano-mechanical resonators

Self-excited vibrational viscometer for high-viscosity sensing

Measurement of Flowing Fluid Viscosity Based on AE Signals

Simultaneous viscosity and density measurement of small volumes of liquids using a vibrating microcantilever

Microrheology measurements with a hanging-fiber AFM probe

Liquid Viscosity Measurement Using a Vibrating Flexure Hinged Structure and a Fiber-Optic Sensor

Liquid viscosity measurement based on disk-shaped electromechanical resonator

A MEMS Resonant Sensor to Measure Fluid Density and Viscosity under Flexural and Torsional Vibrating Modes

Rapid measurement of fluid viscosity using co-flowing in a co-axial microfluidic device

Design and Fabrication of a Microfluidic Viscometer Based on Electrofluidic Circuits

A new method to determine viscosity of liquids using vibration principles

Optomechanical micro-rheology of complex fluids at ultra-high frequency

Study on viscosity measurement using fiber Bragg grating micro-vibration

Use of Torsional Acoustic Resonators for Microweighing, Polymer Rheology, and Monitoring of Biofilm Formation

Brushed Nano‐Stirbars for Measuring Viscosity in Microscopic Systems

Low-consumption photoacoustic method to measure liquid viscosity

Electromagnetically spinning viscometer designed for measurement of low viscosity in low shear rate region

A responsive viscosity sensing system with a flow channel based on a One-Port resonator

High frequency nano-optomechanical disk resonators in liquids

On the use of submerged piezoelectric MFCs for dual viscosity sensing and energy harvesting

Torsional Vibration and Sensitivity Analysis of Microcantilever in Liquid