Abstract:This paper reports a microfluidic viscometer based on electrofluidic circuits for measuring viscosities of liquid samples. The developed micro-device consists of a polydimethylsiloxane (PDMS) layer for electrofluidic circuits, a thin PDMS membrane, another PDMS layer for sample pretreatment, and a glass substrate. As the sample flows inside the microfluidic channel, its viscosity causes flow resistance and a pressure drop along this channel. This pressure drop, in turn, generates a hydraulic pressure which deforms the PDMS membrane, causing changes in the cross-sectional area and the electrical resistance of the electrofluidic resistor. This small resistance change is then measured via the electrofluidic Wheatstone bridge to relate the measured voltage difference to the fluidic viscosity. The performance of this viscometer was first tested by flowing nitrogen gas with controllable pressures into the device. The relationship between measured voltage difference and input gas pressure was analyzed to be linear in the pressure range of 0–15 psi. Another test using pure water indicated good linearity between measured voltage difference and flow rate in the rate range of 20–100 μL/min. Viscosities of glycerol/water solutions with volume/volume (v/v) concentrations ranging from 0 to 30% were measured, and these values were close to those obtained using commercially available viscometers. In addition, the sample-pretreatment layer can be used to mix and/or dilute liquid samples to desired concentrations. Therefore, this microfluidic device has potential for measurements of fluidic viscosity in a fast, accurate, and high-throughput manner.

Liquid Viscosity Measurement Using a Vibrating Flexure Hinged Structure and a Fiber-Optic Sensor

A MEMS Resonant Sensor to Measure Fluid Density and Viscosity under Flexural and Torsional Vibrating Modes

Study on viscosity measurement using fiber Bragg grating micro-vibration

Method of the viscosity measurement by means of the vibrating micro-/nano-mechanical resonators

Liquid viscosity measurement based on disk-shaped electromechanical resonator

Fiber-Optic Viscometer with All-Fiber Acousto-Optic Superlattice Modulated Structure

Determination of Fluid Density and Viscosity by Analyzing Flexural Wave Propagations on the Vibrating Micro-Cantilever

A new method to determine viscosity of liquids using vibration principles

Measurement of Liquid Viscosity and Density Using Single Piezoelectric Resonator with Two Vibration Modes

Mobile phone enabled pervasive measurement of liquid viscosity

Design and Fabrication of a Microfluidic Viscometer Based on Electrofluidic Circuits

Experimental Study on Measuring Liquid Viscosity by Vertical Oscillation of Fusiform Wing Body

Self-excited vibrational viscometer for high-viscosity sensing

Measuring Viscosity Using the Hysteresis of the Non-Linear Response of a Self-Excited Cantilever

Simultaneous viscosity and density measurement of small volumes of liquids using a vibrating microcantilever

Viscosity Measurement Based on Acousto-Optic Effect on Fiber Bragg Grating

Vibration Measurement of Smart Composite Structures by Using the New Intensity Modulated Optical Fiber Sensor

Simultaneous Measurement System of Liquid Density and Viscosity Using Steel Tuning Fork

Microrheology measurements with a hanging-fiber AFM probe

Investigation Of Multifunctional Fiber Optic Sensor In Smart Composite

Determination of liquid viscosity based on dual-frequency-band particle tracking