Abstract:Prediction and optimisation of non-cavitating marine propeller noise at low frequency are important for design of submarine propellers that are required to operate in the non-cavitating condition. The low-frequency discrete- and broadband-spectrum forces of propellers have different generation mechanisms, and thus have not previously been studied within a unified framework. In this work, the strip method is applied to simultaneously predict and optimise these two forces. First, the panel method is applied to predict the discrete-spectrum forces of different strips in the time domain. Then, the unsteady force of the whole propeller is obtained as the linear superposition of the shifted unsteady forces of all the strips, according to a skew distribution. The strip method is then used to numerically solve an integral equation for the broadband-spectrum force, derived via the spectral method. On the basis of experimental results, the predictions of low-frequency discrete- and broadband-spectrum forces are verified to have high accuracies. An analysis of the effect of propeller skew on the unsteady forces of different strips, and the effect of strip-cutting strategy on the broadband-spectrum force, is also performed. It is found that the skew of a strip is approximately equal to the angle of the circumferential phase shift of the unsteady force of that strip, and that the strip-cutting method has an insignificant effect on the predicted broadband-spectrum force. The optimisation of propeller performance under several constraints is then considered, with the particular objectives of maximising the propulsion efficiency and minimising the low-frequency discrete- and broadband-spectrum forces. The circumferential phase-shift effect of the skew allows the optimisation model to be decoupled into two steps. The discrete-spectrum force of the whole propeller can thus be computed using linear superposition rather than a hydrodynamic calculation, which significantly improves the computational efficiency. The effectiveness of the optimisation is verified by two optimization cases. For HSP, the propulsion efficiency is increased by 2.5%, the broadband-spectrum noise is reduced by approximately 0.6 dB, and the first- and second-order values of discrete-spectrum thrust are decreased by 9% and 27%, respectively. Similarly, for E1619, the first- and second-order values of the discrete-spectrum thrust are reduced by 13% and 18%, respectively.

Numerical prediction of scale effect on propeller bearing force of a four-screw ship

Numerical Analysis of Full-scale Ship Self-Propulsion Performance with direct Comparison to Statistical Sea Trail Results

Numerical Study of Hydrodynamic Performance of A High Maneuverability Ocean Engineering Ship with Pod Propeller Design

Research on propeller bearing force of a four-screw ship in oblique flow

Numerical study on the scale effects of two-dimensional cycloidal propellers

Numerical study of the hydrodynamic performances of surface piercing propeller

Influence of scale effect on flow field offset for ships in confined waters

Numerical analysis on dynamic behaviors of coupled propeller-shafting system of underwater vehicles

Numerical study on transient four-quadrant hydrodynamic performance of cycloidal propellers

Numerical Investigation of Unsteady Cavitating Turbulent Flow Around A Full Scale Marine Propeller

Unsteady Numerical Simulation of Cavitating Turbulent Flow Around A Highly Skewed Model Marine Propeller

Numerical simulation to assess hydrodynamic performance of cycloidal propellers during maneuvering

A study on interaction among hull, diesel engine and propellers of a twin-screw ship during turning circle maneuver

Numerical studies on the aeroelasticity of a shipboard helicopter rotor during engagement and disengagement with ship motions using CFD/CSD coupling approach

Propulsion performance of large-scale ship model in real sea environment

Prediction and Optimisation of Low-Frequency Discrete- and Broadband-Spectrum Marine Propeller Forces

Coupling of RANS and BEM Solvers for Simulation of Propeller Behind the Hull in Full Appended Model

Numerical study on unsteady propeller exciting characteristics considering shafting whirling vibration effect

Full-scale simulation of self-propulsion for a free-running submarine

Numerical analysis of wake field and unsteady forces on submarine propeller with twisted rudders

Numerical Study of Cavitating Turbulent Flow Around Propellers: Relationship of Cavity Volume Evolution and Pressure Fluctuation