Abstract:Zero-valent aluminum (ZVAl) is a promising reductant because of its relatively low redox potential, which can efficiently activate molecular oxygen to generate reactive oxygen species. However, its long-term performance is limited by the intrinsic dense oxide layer and the passivation effect of the accumulative Al-(hydr)oxide on its surface during the reaction. In this study, four clay minerals with different compositions were mixed with ZVAl by ball milling to obtain four composites of ZVAl and clay (ZVAl-Clay), which were used to degrade a high concentration of 4-chlorophenol (4-CP) under ambient conditions. The oxidation efficiencies of different ZVAl-Clays were strongly relevant to Fe contained in the clay minerals. The Fe-free ZVAl-Clay presented poor oxidation performance, whereas the reaction efficiencies of those ZVAl composites with Fe-bearing clays exhibited varying degrees of improvement. In comparison with the original ZVAl, the highest oxidation rate increased by 23 times, the maximum increased OH production was approximately 8 times, and the corresponding mineralization efficiency improved by 38.7%. However, the levels of improved oxidation performance of various ZVAl-Clays were not positively correlated with their actual total Fe contents, and their degradation efficiencies might also be affected by other physical and/or chemical properties of different clays. The synergistic mechanism revealed by various characterizations was that electron transfer might occur from ZVAl to the structural Fe(III) of the clay through the basal plane or edge of clays triggered by ball milling. Thus, the partially produced Fe(II) on the clay surface promoted the Fenton-like reaction to decompose H2O2 into OH for efficient oxidation of 4-CP. In short, the ZVAl composites with Fe-bearing clays deserved further exploration as potential materials for efficient degradation of organic matters in wastewater samples.

Broadening the pH range of molecular oxygen activation for zero-valent aluminum by ball-milling surface modification

Catalytic Ozonation of Multiple Vocs at Low Temperature over a Potassium-Modified Mnox-Based Catalyst

Enhanced Conversion from H2O2 to 1O2 on Cu–N Centers: Investigation of Mechanisms and Application in Alkaline Wastewater Treatment

Enhanced reactivity of zero-valent aluminum with ball milling for phenol oxidative degradation

Iron(II) sulfate crystals assisted mechanochemical modification of microscale zero-valent aluminum (mZVAl) for oxidative degradation of phenol in water

The Role of Surface Hydroxyl Concentration on Calcinated Alumina in Catalytic Ozonation

Enhanced Reactivity of Zero-Valent Aluminum/o2 by Using Fe-bearing Clays in 4-Chlorophenol Oxidation.

Molecular oxygen activation by MnO x -anchored aluminum-graphite for micropollutants degradation at near-neutral conditions

Synergistically enhanced activation of persulfate for efficient oxidation of organic contaminants using a microscale zero-valent aluminum/Fe-bearing clay composite

An atom-economic reaction for synthesis of 1-phenoxy-2-propanol over Al2O3/MgO

Oxygen-defective MnO2−x Rattle-Type Microspheres Mediated Singlet Oxygen Oxidation of Organics by Peroxymonosulfate Activation

Promotion of O2 Activation by ZIF-8 Derived N-rich Aluminum-Graphite (Al-Gr-npc) Composite for Non-Radical Degradation of Antibiotic at Neutral Ph

Surface Al and Co coordination for peroxymonosulfate activation: Identification and mechanism

Oxalated Zero Valent Iron Enables Highly Efficient Heterogeneous Fenton Reaction by Self-Adapting Ph and Accelerating Proton Cycle

Labile oxygen-driven catalytic ozonation via surface peroxide pathway for efficient wastewater treatment

Carbon-modified/embedded zero-valent aluminum microparticles will control electron release for efficient adsorption and degradation of aqueous pollutants

Mn-Fe dual-metal Assemblages on Carbon-coated Al2O3 Spheres for Catalytic Ozonation Oxidation: Structure, Performance, and Reaction Mechanism

Rapid hydrogen generation from the reaction of aluminum/activated charcoal composite with alkaline solution

Catalytic Activation of O2 by Al0-CNTs-Cu2O Composite for Fenton-like Degradation of Sulfamerazine Antibiotic at Wide Ph Range.

A highly active bimetallic oxides catalyst supported on Al-containing MCM-41 for Fenton oxidation of phenol solution

Critical roles of low-molecular-weight organic acid in enhancing hydroxyl radical production by ferrous oxidation on γ-Al2O3 mineral surface