Abstract:Monoethanolamine (MEA) based CO2 capture in coal-fired power plants would consume a huge amount of the steam bleed from the steam turbines for the solvent regeneration. The unmatched steam bleed parameters for the solvent regeneration, as well as the huge amount of the process waste heat within the CO2 capture process, inevitably bringing about a significant efficiency penalty. In this study, a novel de-carbonization supercritical coal-fired power plant, which encompasses a supplementary steam turbine (SST), process heat recovery and a modified boiler heating exchangers configuration was proposed. In the proposed system, the steam bleeds for the reboiler and part of the regenerative heaters are coming from the SST, which is located in the upstream of the reheater (steam side), instead of the high and intermediate-pressure turbines (IPT), making the parameters of the steam bleed more matched with the solvent regeneration and feed water heating. In addition, part of the process heat within the CO2 capture/compression unit was efficiently recovered and beneficially used to heat the ambient air before its entering the air pre-heater. The saved flue gas can then be used to heat the feed/condensed water in the low-temperature economizer (LTE), saving part of the steam bleed from the turbines. The configuration of the superheaters/reheaters, as well as the air preheaters were also modified. The mass and energy balance as well as the system thermodynamic performance were determined by the developed models and process simulation. The economic performance of the proposed system was assessed by the cost of electricity (COE) and the cost of CO2 avoided (COA). Finally, the off-design performance of the proposed system was determined. Results showed that the energy efficiency penalty of the proposed system could decrease by 3.86%-points as compared to the reference system. The COE and COA of the proposed system without considering the CO2 transportation and storage cost were $86.11/MWh and $36.92/ton CO2, respectively, both less than those of the reference plant. The off-design operation analysis indicated that the proposed plant also featured a thermodynamics superiority in a wide range of power load variation.

Performance analysis of power plant designed with a carbon capture unit: study of an oil refinery

Conventional and Advanced Exergetic Analysis for the Combined Cycle of Power Plant With Gas Turbine of a Refinery

Energy, Exergy & Environmental Analysis of a Combined Cycle with Pre-combustion CO2 Capture and N2 Injected into the Compressor of the Gas Turbine

Techno-Economic Efficiency Estimation of Promising Integrated Oxyfuel Gasification Combined-Cycle Power Plants with Carbon Capture

Technical-Economic Analysis of Energy Efficiency Solutions for the Industrial Steam System of a Natural Gas Processing Plant

Optimizing post-combustion carbon capture: A comprehensive 3E analyses of energy, exergy, and exergoeconomic aspects with solar integration

Energy, Exergy, Economic, and Environmental Analysis of an Integrated System of High-Temperature Heat Pump and Gas Separation Unit

Exergetic investigation and performance optimisation of a supercritical power plant

Influence of Gas Turbine Exhaust CO2 Concentration on the Performance of Post Combustion Carbon Capture Plant

Carbon Capture Performance Assessment Applied to Combined Cycle Gas Turbine Under Part-Load Operation

Techno-economic, techno-environmental assessments, and deep learning optimization of an integrated system for CO 2 capturing from a gas turbine: Tehran case study

Energy and Economic Assessment of Oxy-Fuel Combustion CO2 Capture in Coal-Fired Power Plants

Industrial test of post combustion CO2 capture by reactive absorption with two new solvents in natural gas power plant

Performance assessment and system optimization on supercritical CO 2 double-path recompression coal-fired combined heat and power plants with MEA-based post-combustion CO 2 capture

Process and Integration Optimization of Post-Combustion CO2 Capture System in a Coal Power Plant

An integrated de-carbonization supercritical coal-fired power plant incorporating a supplementary steam turbine, process heat recovery and a modified boiler structure

Exergetic Analysis of a Natural Gas Combined-Cycle Power Plant with a Molten Carbonate Fuel Cell for Carbon Capture

Economic and operational assessment of solar-assisted hybrid carbon capture system for combined cycle power plants

Thermodynamic and economic analysis of performance evaluation of all the thermal power plants: A review

Energy, exergy and economic analysis of utilizing the supercritical CO2 recompression Brayton cycle integrated with solar energy in natural gas city gate station

Optimization of Post Combustion CO2 Capture from a Combined-Cycle Gas Turbine Power Plant via Taguchi Design of Experiment