Abstract:As a promising candidate of rare-earth free hard magnetic materials, L10-FeNi has been paid much attention in the last decades. However, it is difficult to be artificially fabricated due to its low thermal stability and sluggish diffusion ability of atoms below the crucial temperature of 320 °C. In this study, a promising method of annealing amorphous precursor was extensively developed through (Fe50Ni50)84−xSixP16 (x = 0, 4 at%) and (Fe50Ni50)86−xSixP14 (x = 2, 4, 8 at%) alloys. Especially, the effect of Si on the formation of L10 phase in annealed FeNi-based alloys was investigated and clarified. It is found Fe42Ni42P16 with a much low crystallization temperature could be an appropriate basic amorphous alloy for the formation of L10 phase. The addition of Si enhanced the thermal stability of Fe-Ni-P amorphous alloys. Interestingly, Si could stabilize the L10 phase in annealed samples and increase its disordering temperature above which L10-FeNi phase could deteriorate into soft magnetic phase. As expected, appropriate Si addition indeed improved the hard magnetic properties of the annealed alloys and samples with high coercivity above 900 Oe was obtained. Further Si addition would deteriorate the magnetic-crystalline anisotropy of L10 phase and decrease the coercivity of annealed Fe-Ni-Si-P alloys. Nevertheless, the results indicate that increasing the order-disorder transition temperature through element doping in L10 lattice would be a promising strategy for the massive formation of L10-FeNi like other ordered phases (i.e. L12-FeNi, L10-CoPt), and could substantively contribute to the artificial fabrication of FeNi-based rare-earth free magnets in future.

Magnetic Properties and Crystal Structure of (Fe,Ni)2( P,Si) Quaternaries of Fe2P-Type

Optimizing the Sintering Conditions of (Fe,Co)1.95(P,Si) Compounds for Permanent Magnet Applications

Structure-Magnetic Relationships in the Fe-Mn-P-Si System for Energy Applications

Direct and Alternating Current Magnetic Properties of FeNi Particles Coated with SiO2

Magnetic And Structural Properties Of Ca(Fe1-Xcox)(2)P-2 And Ca(Ni1-Xcox)(2)P-2

Structural transitions, magnetic properties, and electronic structures of Co(Fe)-doped MnNiSi compounds

X-ray Absorption Near-Edge Structure Spectroscopy Research on Electronic Structures and Magnetic Properties of (Fe1-Xnix)2p

Microstructure Formation and Magnetocaloric Effect of the Fe2P-type Phase in (mn,fe)2(p, Si, B) Alloys

Effect of M/NM Ratios on Structural and Magnetic Properties of (mn,fe)2(p,si) Compounds

Magnetic and structural properties of ferromagnetic Fe5PB2 and Fe5SiB2 and effects of Co and Mn substitutions

Electronic Structure and Magnetism of R(Fe,Si)(12) (R = Y, Nd)

Structure and Magnetic Properties of DyFe10Si2Nx Compounds

Tailoring the thermal stability and soft magnetic properties of Fe80-Ni Si7B8P4Cu1 amorphous nanocrystalline alloys based on the magnetic domain structure

Itinerant Antiferromagnetism in FeMnP0.8Si0.2 Single Crystals

Structural, Magnetic Properties and Magnetocaloric Effect of Mn1.2Fe0.8P1−Si B0.03 Compounds

Study of Interdiffusion and Magnetization of Cu-Doped Fe/Ni Multilayers

Effect of Si addition on the magnetic properties of FeNi-based alloys with L10 phase through annealing amorphous precursor

Effects of P addition on the glass forming ability, crystallization behaviour and soft magnetic properties of FeNi-based amorphous alloy

Structure And Magnetic Properties Of Nanocrystalline Fe73.5cu1nb3-Xtixsi13.5b9 (X=0, 1, 2, 3) Powders

Influences of P Doping on Magnetic Phase Transition and Structure in MnCoSi Ribbon

Self-organized magnetic assemblies of (001) oriented FePt nanoparticles with SiO<sub>2</sub> additive