Abstract:The capture and sequestration of CO2 generated from large-scale stationary power plants is considered to be one of the leading technologies that could potentially have a significant impact on reducing greenhouse emissions. Among these emerging technologies, the oxy-fuel combustion is a near-zero emission technology that can be adapted to both new and existing pulverized coal-fired power stations. The goal of this work is to make a comparative study on char structural characteristics (including char yield, swelling ratio, BET surface area, pore distribution, morphology) and reactivity during conventional air and oxy-fuel combustion. Specific experimental designs include two series. One is carried out in pure N-2 and CO2 (pyrolysis experiments), and another is prepared in N-2+5%O-2 and CO2+5%O-2. Coal samples included raw coal, low density fraction coal and medium density fraction coal in all experiments. The present study is a further effort to extend our knowledge about physical and chemical structural characteristics and reactivity of char in the presence of high concentration CO2. Combustion and pyrolysis of a density fractionated China coal at drop tube furnace yielded the following conclusions. Compared to oxy-chars obtained under pure CO2 atmosphere, the swelling ratios of char obtained in pure N-2 atmosphere are higher. When adding 5% O-2, experimental results are completely different with those of the pyrolysis experiment. In comparison with the oxy-chars obtained under CO2 + 5%O-2 atmosphere, the swelling ratios of the char obtained in N-2 + 5%O-2 atmosphere are lower. In the pyrolysis experiment, the BET surfaces Area of the oxy-chars are about ten to twenty times as much as chars. When adding 5% O-2, the BET surfaces Area of the oxy-chars are about two to four times as much as chars. During pyrolysis experiment, the total pore volumes of the oxy-chars obtained under pure CO2 are larger in comparison with chars obtained in pure N-2. The pore distributions of the oxy-chars are mainly mesopore and the chars have macropore mostly. The micropore and mesopore volume of oxy-chars are about ten times as much as chars separately and the macropore volume of oxy-chars are about two times as much as chars. When adding 5% O-2, the total pore volumes of the oxy-chars obtained under CO2 + 5%O-2 are also larger in comparison with chars obtained in N-2 + 5%O-2. In the pyrolysis experiment, the reactivity indexes of oxy-chars obtained under pure CO2 are lower in comparison with chars obtained in pure N-2. When adding 5% O-2, no significant differences can be observed, which may be due to the ordering of carbon microcrystalline structure. In pure CO2 atmosphere, the oxy-chars have a highly order polycrystalline structure, but chars obtained at pure N-2 atmosphere have a highly disordered carbonaceous structure.

Iron based oxygen-carrier-aided oxy-fuel combustion of coal char: Reactivity and oxygen transfer mechanism

Analysis of Characteristics and Mechanisms of Iron-Based Oxygen Carrier-Aided Oxy-Fuel Combustion of Coal Char in a Bubbling Fluidized Bed

Oxy-fuel Combustion of a Single Fuel Particle in a Fluidized Bed: Char Combustion Characteristics, an Experimental Study

Oxygen-Carrier-Aided Combustion in a Bench-Scale Fluidized Bed

Quantitative Analysis of Catalytic Oxidation Reactions in Oxygen Carrier Aided Fluidized Bed Combustion

NOx and SO2 Emission of Oxygen Carrier Aided Combustion in Fluidized Bed

O2/CO2 and O2/N2 Combustion of Bituminous Char Particles in a Bubbling Fluidized Bed under Simulated Combustor Conditions

Measurements and Modelling of Oxy-Fuel Coal Combustion

Improvement of coal and Petroleum coke combustion in a fluidized bed by using ilmenite ore as bed material

Formation and O2/CO2 Combustion Characteristics of Real-Environment Coal Char in High-Temperature Oxy-Fuel Conditions

Combustion Interactions of Blended Coals in an O-2/CO2 Mixture in a Drop Tube Furnace: Experimental Investigation and Numerical Simulation

Experimental Study on Coal Combustion by Using the Ilmenite Ore As Active Bed Material in a 0.3 MWth Circulating Fluidized Bed

Investigation on Iron Ore for the Oxygen Carrier Aided Combustion

Study on the Interaction of the Fe-Based Oxygen Carrier with Ashes

Study on the Surface Active Reactivity of Coal Char Conversion in O2/CO2 and O2/N2 Atmospheres

Kinetic Characteristics of Coal Char Combustion in Oxygen-Enriched Environment

Dynamic Modeling of Oxygen Carrier-Aided Combustion in a Packed Bed Reactor

Combustion Interactions of Blended Chars under Oxidation and Gasification Competition in Oxy–Fuel Condition

Comparison Of Char Structural Characteristics And Reactivity During Conventional Air And Oxy-Fuel Combustion

Study on Combustion Characteristic of Coal-Char in Oxygen-Enriched Environments

Experimental Investigation of the Combustion of Bituminous Coal in Air and O-2/Co2 Mixtures: 1. Particle Imaging of the Combustion of Coal and Char