Abstract:Gas-liquid two-phase flows frequently occur in various flow channels in engineering systems with heat and mass transport processes. The channel geometry affects thermo-fluid behavior generally. Extensive research is done on gas-liquid two-phase flows in circular and annular channels with a wealth of local two-phase flow measurement data. Square channels are used in various engineering disciplines, but there has only been limited experimental research on two-phase flows in square channels with local flow parameter measurements. For two-phase flow analyses in square channels, knowledge of the flow characteristics and model validation against some key parameters, such as the drift-flux parameters and the interfacial area concentration, is crucial. An experiment for upward bubbly flows was conducted in a large square channel with an inside cross-section of 0.136 x 0.136 m. A four-sensor optical probe and a hotfilm anemometer were used to measure local two-phase flow parameters at 66 points in an octant symmetric triangular cross-section at three axial locations. The measured two-phase flow parameters were the void fraction, axial gas velocity, axial liquid velocity, interfacial area concentration, and bubble Sauter mean diameter. The flow characteristics through flow development were investigated based on the local measurement data. The local measurement data directly determined the drift-flux parameters through their definitions. The distribution parameters determined through experimentation could be reproduced by the existing correlation for large circular pipes indicating that the flow characteristics in large square channels may be similar to those in large circular pipes. Based on existing drift-flux correlations for large circular pipes, the void fractions in the current experiment could be fairly predicted. Furthermore, the interfacial area concentrations could be predicted by existing correlations with reasonable accuracy. (c) 2023 Elsevier Ltd. All rights reserved.

Taylor bubble flow distribution in multi cross-branched microchannels: a numerical investigation

EFFECTS OF INLET ARRANGEMENTS ON LIQUID-LIQUID FLOW PATTERNS IN CROSS-JUNCTION SQUARE MICROCHANNELS

Taylor bubble splitting, flow and coalescence in branching microchannels: An experimental and numerical simulation study

Effects of the Outlet Pressure on Two-Phase Slug Flow Distribution Uniformity in a Multi-Branch Microchannel

Experimental study of Taylor bubble flow in non-Newtonian liquid in a rectangular microchannel

The bubble breakup process and behavior in T-type microchannels

A Comparative Study of Two Numerical Methods Applied for 3D Liquid-Liquid Taylor Flow in a Microchannel

Experimental visualization of bubble generation and breakup in T-junctions of microchannels

Multi-dimensional Characteristics of Upward Bubbly Flows in a Vertical Large-Size Square Channel

Experimental and numerical study on the transport of dilute bubbles in a T-junction channel flow

Bubble Splitting under Gas–liquid–liquid Three‐phase Flow in a Double T‐junction Microchannel

Taylor Bubble Generation Rules in Liquids with a Higher Viscosity in a T-Junction Microchannel

Dynamics of Bubble Formation in Highly Viscous Liquid in Co-Flowing Microfluidic Device

Mixing Efficiency Analysis On Droplet Formation Process In Microchannels By Numerical Methods

Behind the Non-Uniform Breakup of Bubble Slug in Y-Shaped Microchannel: Dynamics and Mechanisms

Experimentally Investigating Phase Separation and Pressure Drop As Bubbly Flow in a Vertical Branching T-junction

Impact of flow feedback on bubble generation in T-junction microchannels under pressure-driven condition

Geometric Effect on Gas–Liquid Bubbly Flow in Capillary-Embedded T-Junction Microchannels

Controllable Gas-Liquid Phase Flow Patterns And Monodisperse Microbubbles In A Microfluidic T-Junction Device

FORMATION OF NANOLITER BUBBLES IN MICROFLUIDIC T-JUNCTIONS

Comparative Analysis of Gas–liquid Flow in T-junction Microchannels with Different Inlet Orientations