Abstract:Efficient separation and high-valued utilization of coal gasification ash or slag limit the clean and green development of coal chemical industry. In this paper, a coal-water slurry gasification fine slag (CWSFS) was studied by wet screening and classification. The relationship between the particle composition with different sizes and the structural characteristics was investigated by means of proximate analysis, XRF, XRD, BET and SEM. A classification method of CWSFS was proposed to guide the high-valued utilization of coal gasification slag. Then, dry separation of a coal-water slurry gasification fine slag was carried out using a combined treatment method of crushing and dissociation and airflow classification. The results show that the CWSFS particles of different sizes have obvious differences in fixed carbon content, ash composition and mineral types. For the CWSFS with the particle size above 74 μm, the fixed carbon content is more than 60%, the calorific value is more than 20 MJ/kg, the specific surface area is relatively high and the main component is the residual carbon that contains magnetite and brookite. For the CWSFS with particle sizes between 13–74 μm, the fixed carbon content is between 20%–60%, the calorific value is between 11–19 MJ/kg, the specific surface area is small and the main mineral types are pyroxene, marcasite and hematite, etc. For the CWSFS with a particle size between 0–13 μm, the fixed carbon content is less than 20% and the calorific value is less than 10 MJ/kg, which mainly includes the amorphous glass phase that was rich in aluminum, iron and calcium, quartz and a small amount of fayalite, muscovite and other minerals. According to the fixed carbon content of CWSFS with different particle sizes, the above three components with varying particle size ranges are defined as high-carbon component, medium-carbon component and low-carbon component, respectively. The dry separation test shows that the air flow crushing and classification process can achieve a higher product yield of 29.60% and a high ignition loss of 93.76%, compared to the traditional disc crushing-classification process. Airflow crushing was proved to be able to effectively increase the dissociation degree of residual carbon and greatly improve the separation and enrichment rate of residual carbon.

Study on the modification of the coarse coal-slime separation process in Lv-jiatuo coal preparation plant

Studies of a Water-Only Cyclone with a Three-Stage Cone for Fine Coal Beneficiation

A Feed-regulated Water-only Cyclone for Improving the Separation Performance of Clean Coal from Coal Slime

Study on the composition and structure characteristics and dry decarbonization separation of coal water slurry gasification fine slag

ICOPE-15-C071 the Study on Agglomeration and Removal of Fine Particles in Wet Phase Transition Condensation Process

Experimental and theoretical study on strengthening mechanism of coarse coal slime classification process with cone wall structure

Study on preparation of high mass fraction coal-water slurry from Huating coal

REVAMPING OF FCC UNIT WITH CSC RAPIDSEPARATION TECHNOLOGY

Experimental Study on Slagging Characteristic of Low-volatile Coal Water Slurry in a 220t/h Boiler

Application of cyclonic microbubble flotation column in Xiezhuang coal preparation plant: From laboratory to industrial scale

Enhanced coarse coal slime separation in a gravity–flotation coupled separator with up-flow feeding and dual-concentrate

Hot Water Treatment of Low Rank Coal in High Temperature and High Pressure Reactor and Its Slurry Ability

Upgrade of Low Rank Coal by Using Emulsified Asphalt and Its Application for Preparation of Coal Water Slurry with High Concentration

Research on the slurrying performance of coal and alkali-modified sludge

Pilot-Scale Investigation on Slurrying, Combustion, and Slagging Characteristics of Coal Slurry Fuel Prepared Using Industrial Wasteliquid

On-site source-separation of microparticles and reuse of coal gasification wastewater via a micro-channel separator: Performance and separation mechanism

Experimental Research Of Controllable Pulverized Coal Rich/Lean Swirl Combustion Technology

Modeling and optimization of scrubbing process of coal-water slurry gasification plant

Preparation and performance of multi-ionic composite coagulants based on coal gasification coarse slag by one-step acid leaching

Preparation of High Concentration Coal Water Slurry with Good Fluidity Based on Only Modified Fine Particles under Bimodal Distribution Using the Second Fluid and the Second Particle

STUDY ON SLURRYABILITY OF COAL WATER SLURRY USED FOR COAL GASIFICATION