Abstract:This study aimed to investigate the liquid–liquid equilibrium (LLE) behavior of sesame fatty acid ethyl ester (FAEE) and methyl ester (FAME) in combination with glycerol and the co-solvents ethanol and methanol. FAEE and FAME were produced through the transesterification of mechanically extracted and purified sesame oil, using potassium hydroxide (KOH) as a homogeneous base catalyst. The reactions were conducted in ethanol and methanol to produce FAEE and FAME, respectively. Post-reaction, the products were separated and purified, followed by an analysis of the LLE behavior at 313.15 K and 323.15 K under atmospheric pressure (101.3 kPa). The experimental process for the miscibility analysis utilized a jacketed glass cell adapted for this study. Miscibility limits or binodal curves were determined using the turbidity-point method. Tie lines were constructed by preparing mixtures of known concentrations within the two-phase region, which allowed the phases to separate after agitation. Samples from both phases were analyzed to determine their composition. This study revealed that higher temperatures promoted greater phase separation and enhanced the biodiesel purification process. The NRTL model effectively correlated the activity coefficients with the experimental data, showing good agreement, with a root-mean-square deviation of 3.5%. Additionally, the data quality was validated using Marcilla's method, which yielded an R2 value close to 1. Attraction factors and distribution coefficients were also calculated to evaluate the efficiency of the co-solvents as extraction agents. The findings indicated higher selectivity for methanol than for ethanol, with varying degrees of distribution among the co-solvents. These results offer significant insights into enhancing biodiesel production processes by considering the effects of co-solvents on the LLE properties of mixtures, ultimately contributing to more efficient and cost-effective biodiesel production.

Investigating the high‐shear mixed catalytic esterification of lauric acid with methanol using central composite design

Synthesis and Optimization of Methyl Laurate Using Sulfonated Pyrrolidonium Ionic Liquid as a Catalyst

Esterification of Free Fatty Acids Using Layered Carboxylates and Hydroxide Salts as Catalysts

Optimization of solvent-free enzymatic esterification in eutectic substrate reaction mixture

Effect of La-Fe/Si-MCM-41 Catalysts and CaO Additive on Catalytic Cracking of Soybean Oil for Biofuel with Low Aromatics

Methanesulfonic Acid As a More Efficient Catalyst for the Synthesis of Lauraldehyde Glycerol Acetal

Catalytic production of biodiesel from esterification of lauric acid over a solid acid hybrid

Selective Catalytic Synthesis of Glycerol Monolaurate over Silica Gel-Based Sulfonic Acid Functionalized Ionic Liquid Catalysts

Heterogeneization of Biodiesel Production by Simultaneous Esterification and Transesterification of Oleins

Caesium Salt of Tungstophosphoric Acid Supported on Mesoporous SBA-15 Catalyst for Selective Esterification of Lauric Acid with Glycerol to Monolaurin

Enzymatic esterification of lauric acid to give monolaurin in a microreactor

Organic Solvent‐free Transesterification of Various Starches with Lauric Acid Methyl Ester and Triacyl Glycerides

Data on the derived mesoporous based catalyst for the synthesized of fatty acid methyl ester (FAME) from ternary oil blend: An optimization approach

Balance between Catalyst Acidity and Hydrophilicity in Biofuel Production from Fatty Acid Esterification over Al-SBA-15

A new heterogeneous acid catalyst system for esterification of free fatty acids into methyl esters

Liquid–Liquid Equilibrium of Sesame Fatty Acid (Ethyl and Methyl) Ester + Glycerol + Ethanol/Methanol Mixtures at Different Temperatures

Tannin-derived bimetallic CuCo/C catalysts for an efficient in-situ hydrogenation of lauric acid in methanol-water media

Complete Kinetic Model for Esterification Reaction of Lauric Acid with Glycerol to Synthesize Glycerol Monolaurate

Highly Active Silver ion-Exchanged Silicotungstic Acid Catalysts for Selective Esterification of Glycerol with Lauric Acid

Mesoporous Sulfonic Acids as Selective Heterogeneous Catalysts for the Synthesis of Monoglycerides