Abstract:In order to reduce the dust pollution caused by drilling and blasting in high altitude tunnel construction, improve the dust control technology and occupational health guarantee ability in tunneling face, and promote the clean production level in tunnel construction, the forced ventilation model of tunnel blasting was established on the basis of a working area in southwest railway tunnel, and the dust pollution dynamics model of high altitude tunnel was built according to the gas-solid two-phase flow theory and aerosol mechanics. The numerical simulation software was used to analyze the pollution effect of high-concentration dust in blasting-driven tunnel under different altitudes, ventilation distances and ventilation air volumes, and the grey correlation analysis method was used to explore the correlation between the time required for the dust concentration to decrease to a safe value and various influencing factors. The results show that the environmental parameters and the movement characteristics of gas-solid coupling fluid will change with the elevation. The horizontal movement speed of dust particles is negatively correlated with elevation and dust particle size, while the vertical settling speed is opposite. The spatial distribution of dust concentration after tunnel blasting at high altitude obeys multivariate Gaussian distribution, and the diffusion coefficient increases with the increase of altitude. The distribution area of wind field in tunnel is divided into vortex area, transition area and stable area. The vortex area is cone-shaped and the wind speed in the center is lower than that in the surrounding area. The average wind speed in tunnel section decreases to about 0.3 m/s and gradually stabilizes. After blasting, the dust particles move out of the tunnel in a “?” shape with the wind, and the dust concentration at the return air side of the tunnel is higher than that at the air duct side. The large particle dust（particle size ≥30 μm） produced after blasting rapidly settles within 100 m from the tunnel face, and the small particle dust will diffuse with the wind and be suspended in the tunnel space, and the farther the diffusion distance is, the smaller the particle size of the dust will be. With high tunnel altitude, expanding the distance between the outlet of air duct and the tunnel face and increasing the air volume of air duct are all beneficial to reduce the dust pollution effect after tunnel blasting. The time required for the dust concentration in the tunnel to decrease to a safe value is most affected by the ventilation distance, followed by the air volume, while the influence of altitude is relatively limited, and its grey correlation coefficient is 0.684, 0.678 and 0.661 respectively.

The effect of oxygen supply and oxygen distribution on single-head tunnel with different altitudes under mixed ventilation

Optimization of controlled circulating ventilation and oxygen supply scheme for high-altitude mine heading face based on CFD

Increasing Oxygen Mass Fraction in Blind Headings of a Plateau Metal Mine by Oxygen Supply Duct Design: A CFD Modelling Approach

Study on the Oxygen Enrichment Effect of Individual Oxygen-Supply Device in a Tunnel of Plateau Mine

Optimization for diffusion-type oxygen supply nearby working face of railway tunnel in plateau

On the oxygen-intensifying ventilation technology for plateau mine tunneling via the application of the software Fluent

Study on the Effect of Oxygen Supplementation for Tunneling Workers of Plateau Mine

Technologies of Oxygen Supply for Life Support During the Development of Mineral Resources in High Altitude Areas

Relative Importance of Certain Factors Affecting Air Exchange in a High-Altitude Single-Heading Tunnels Based on the Numerical Simulation Method

Study of Construction Control Technology for Super-long High Altitude Highway Tunnel in Low Pressure and Low Oxygen Environment: Technical Standards for Oxygen Supply, Key Ventilation Technology, Construction Personnel Organization and Construction Equipment Efficiency

Study on Oxygen Supply Standard for Physical Health of Construction Personnel of High-Altitude Tunnels

Study on CO Diffusion Law and Concentration Distribution Function under Ventilation after Blasting in High-Altitude Tunnel

Research On Oxygen-Increasing Ventilation In Alpine Region

STUDY ON TECHNOLOGY OF OXYGEN SUPPLY IN TUNNEL DEVELOPMENT IN HIGH ATTITUDE AREA

Study on oxygen concentration distribution of Sejila mount tunnel construction based on fluent

A numerical study on CO migration after blasting in high-altitude tunnel by inclined shaft

Novel oxygen-enrichment method using annular air curtain for single-head roadway of plateau mine

Oxygen Concentrating and Application for Railway Tunnel Construction in High Altitude Area and It's Physiological Effects on the Construction Workers

Dynamic Model and Influencing Factors of Dust Pollution after Blasting in High Altitude Tunnel

Pulmonary Capacity, Blood Composition and Metabolism among Coal Mine Workers in High- and Low-Altitude Aboveground and Underground Workplaces

Diffusion Characteristics of Airflow and CO in the Dead-End Tunnel with Different Ventilation Parameters after Tunneling Blasting