Abstract:Municipal solid waste (MSW) and sewage sludge (SS) co-pyrolysis have the potential to revolutionize waste management and address energy challenges. Consequently, it is crucial to explore the thermal and synergistic effect of MSW, SS and their blends using thermogravimetric analysis. Different blending ratios (MSW90%SS10 %, MSW80%SS20 % and MSW65%SS35 %) were analyzed under an inert nitrogen (N 2 ) gas atmosphere, at various heating rates (10,20 and 30 K min −1 ), from 30 °C to 900 °C. This paper specifically addressed the effect of heating rate and blending ratio on separate and jointed pyrolysis of the two raw materials. The analysis revealed two significant decomposition stages observed in the individual pyrolytic processes and their blends. Results showed that a higher heating rate slowed down the decomposition rate due to less effective heat transfer. The blending ratio of 35 % SS at 20 K min −1 exhibited a positive synergistic effect while an antagonistic effect was observed in another mixing ratio. Activation energy determined using the Coats-Redfern model in the second stage of active pyrolysis for MSW90%SS10 %, MSW80%SS20 % and MSW65%SS35 % was 41.879, 43.365 and 40.271 kJ mol −1 respectively. The negative ΔS (entropy) and positive ΔH (enthalpy) values indicated a decrease in disorder and an endothermic reaction respectively. This finding was consistent with the formation of complex products from the feedstock and the endothermic nature of the pyrolysis process. Therefore, strategic co-pyrolysis optimization of MSW and SS with the precise blending ratio of 35 % sewage sludge and controlled heating rate of 20 K min −1 , exhibits substantial potential for advancing eco-friendly waste management practices while enabling effective energy recuperation.

Investigation on Thermal and Kinetic Characteristics During Pyrolysis and Co-Pyrolysis of Recovered Fuels Obtained From Municipal Solid Waste in China

Analysis on low-temperature polyethylene pyrolysis and gasification in different atmospheres

Investigation on the co-pyrolysis of municipal solid waste and sawdust: pyrolysis behaviors, kinetics, and thermodynamic analysis

Study on the pyrolysis and combustion characteristics of municipal solid waste in a fixed bed

Investigation of thermal behaviour and synergistic effect in co-pyrolysis of municipal solid waste and sewage sludge through thermogravimetric analysis

TGA Pyrolysis and Gasification of Combustible Municipal Solid Waste

Experimental and Kinetic Modeling of Oxygen-Enriched Air Combustion of Municipal Solid Waste.

PYROLYTIC KINETICS OF COMBUSTIBLE OF MSW

The Thermal Behavior and Kinetics of Co-Combustion Between Sewage Sludge and Wheat Straw

Pyrolysis characteristics of organic components of municipal solid waste at high heating rates.

Investigation of Catalytic Co-Pyrolysis Characteristics and Synergistic Effect of Oily Sludge and Walnut Shell

Investigation of co-pyrolysis characteristics and kinetics of municipal solid waste and paper sludge through TG-FTIR and DAEM

Co-pyrolysis of Corn Stover and Waste Tire: Pyrolysis Behavior and Kinetic Study Based on Fraser-Suzuki Deconvolution Procedure

Solid Waste as a Renewable Source of Energy: A Comparative Study on Thermal and Kinetic Behavior of Three Organic Solid Wastes

Study on the pyrolysis characteristics of the mixture of typical organic components of MSW

Effect of Operating Parameters and Moisture Content on Municipal Solid Waste Pyrolysis and Gasification

Thermogravimetric characteristics of typical municipal solid waste fractions during co-pyrolysis.

Study on Pyrolysis and Gasification of Wood in MSW

Thermal and Kinetic Behaviors During Co-Pyrolysis of Microcrystalline Cellulose and Styrene–Butadiene–Styrene Triblock Copolymer

Thermogravimetry Analysis Technique of Compounded Fuel

Thermogravimetric analysis of the co-combustion of paper mill sludge and municipal solid waste