Abstract:A novel phosphorous (P) removal and recovery process using a membrane bioreactor (MBR) with ferric iron dosing and acidogenic co-fermentation was developed for municipal wastewater treatment. The very different solubility of Fe(III)-P and Fe(II)-P complex and the microbial transformation of Fe(III) to Fe(II) were utilized for P removal and recovery. By means of Fe-induced precipitation, chemical P removal was effectively achieved by an MBR with a flat-plate ceramic membrane; however, the Fe(III)-P solids accumulated in the MBR that constituted a significant fraction of the activated sludge. Anaerobic co-fermentation of the MBR sludge and food waste in a side-stream allowed the extraction of P and Fe from the sludge into the supernatant. The P in the supernatant was recovered as a fertilizer resource, while the sludge was returned to the MBR tank. The experimental results show that by adding FeCl3 at 20 mg Fe/L into the influent of domestic wastewater, about 95.6% of total P could be removed by the MBR. One fifth (20%) of the sludge in the MBR was circulated daily through the side-stream fermenters for co-fermentation with cooked rice as the model food waste. The sludge underwent acidogenesis and dissimilatory iron reduction, resulting in a drop of the pH to below 5.0 and reduction of Fe(III) to Fe(II). Owing to the high solubility of the Fe(II)-P complex, P and Fe were then dissolved and released from the sludge into the supernatant. By simply adjusting the solution pH to 8.0, the P and Fe(II) in the supernatant readily re-precipitated to form vivianite for the P recovery. Using the iron dosing MBR and side-stream sludge fermentation, an overall P recovery efficiency of 62.1% from wastewater influent can be achieved, and the problem of inorganic build-up in the MBR is effectively alleviated.

Phosphorus Recovery by Adsorption from the Membrane Permeate of an Anaerobic Membrane Bioreactor Digesting Waste-Activated Sludge

Phosphate recovery from the P-enriched brine of AnMBR-RO-IE treating municipal wastewater via an innovated phosphorus recovery batch reactor with nano-sorbents

Remove and Recover Phosphorus During Anaerobic Digestion of Excess Sludge by Adding Waste Iron Scrap

Phosphorus release and realignment in anaerobic digestion of thermal hydrolysis pretreatment sludge – Masking effects from high ammonium

Enhancing Phosphorus Recovery from Efficient Acidogenic Fermentation of Waste Activated Sludge with Acidic Cation Exchange Resin Pretreatment: Insights from Occurrence States and Transformation

Feasibility of Wastewater Resource Recovery Using Pilot-Scale Membrane Reactor with Long-Term Operation

Phosphorus Removal and Recovery From Anaerobic Digestion Residues

A Membrane Bioreactor with Iron Dosing and Acidogenic Co-Fermentation for Enhanced Phosphorus Removal and Recovery in Wastewater Treatment

A new process for simultaneous nitrogen removal and phosphorus recovery using an anammox expanded bed reactor

Efficient phosphorus recovery from waste activated sludge: Pretreatment with natural deep eutectic solvent and recovery as vivianite

Acidogenic Phosphorus Recovery from the Wastewater Sludge of the Membrane Bioreactor Systems with Different Iron-Dosing Modes.

Adsorptive behavior of phosphorus onto recycled waste biosolids after being acid leached from wastewater sludge

Acid treatment enhances phosphorus release and recovery from waste activated sludge: Performances and related mechanisms

Microwave-assisted Digestion and NaOH Treatment of Waste-Activated Sludge to Recover Phosphorus by Crystallizing Struvite.

Integrating Chemical Precipitation and Membrane Separation for Phosphorus and Ammonia Recovery from Anaerobic Digestate

Phosphorus recovery from sludge by pH enhanced anaerobic fermentation and vivianite crystallization

Selective Recovery of Phosphorus from the Leachate of Incinerated Sewage Sludge Ash Using the Zr-modified Acid-Leaching Residue As Adsorbent for Two-Fold Resource Utilization

An Innovative Membrane Bioreactor (MBR) System for Simultaneous Nitrogen and Phosphorus Removal

Enhanced waste activated sludge digestion using a submerged anaerobic dynamic membrane bioreactor: performance, sludge characteristics and microbial community

Development of a novel phosphorus recovery system using incinerated sewage sludge ash (ISSA) and phosphorus-selective adsorbent

Harnessing sustainable opportunities for nutrient removal and recovery from liquid digestate in a modern municipal food waste biogas power plant