Abstract:Heavier-than-air flight at any scale is energetically expensive. This is greatly exacerbated at small scales and has so far presented an insurmountable obstacle for untethered flight in insect-sized (mass less than 500 milligrams and wingspan less than 5 centimetres) robots. These vehicles<a href="#ref-CR1">1</a>,<a href="#ref-CR2">2</a>,<a href="#ref-CR3">3</a>,<a href="/articles/s41586-019-1322-0#ref-CR4">4</a> thus need to fly tethered to an offboard power supply and signal generator owing to the challenges associated with integrating onboard electronics within a limited payload capacity. Here we address these challenges to demonstrate sustained untethered flight of an insect-sized flapping-wing microscale aerial vehicle. The 90-milligram vehicle uses four wings driven by two alumina-reinforced piezoelectric actuators to increase aerodynamic efficiency (by up to 29 per cent relative to similar two-wing vehicles<a href="/articles/s41586-019-1322-0#ref-CR5">5</a>) and achieve a peak lift-to-weight ratio of 4.1 to 1, demonstrating greater thrust per muscle mass than typical biological counterparts<a href="/articles/s41586-019-1322-0#ref-CR6">6</a>. The integrated system of the vehicle together with the electronics required for untethered flight (a photovoltaic array and a signal generator) weighs 259 milligrams, with an additional payload capacity allowing for additional onboard devices. Consuming only 110–120 milliwatts of power, the system matches the thrust efficiency of similarly sized insects such as bees<a href="/articles/s41586-019-1322-0#ref-CR7">7</a>. This insect-scale aerial vehicle is the lightest thus far to achieve sustained untethered flight (as opposed to impulsive jumping<a href="/articles/s41586-019-1322-0#ref-CR8">8</a> or liftoff<a href="/articles/s41586-019-1322-0#ref-CR9">9</a>).

A wireless radiofrequency-powered insect-scale flapping-wing aerial vehicle

Untethered flight of an insect-sized flapping-wing microscale aerial vehicle

Design and Experiment for Realization of Laser Wireless Power Transmission for Small Unmanned Aerial Vehicles

Review on Ultra-Lightweight Flapping-Wing Nano Air Vehicles: Artificial Muscles, Flight Control Mechanism, and Biomimetic Wings

A Fast-Beamforming Technique for Blind-Adaptive Wireless Power Transfer Towards Free-Flying Insects.

Liftoff of an Electromagnetically Driven Insect-Inspired Flapping-Wing Robot

Mighty: Towards Long-Range and High-Throughput Backscatter for Drones

A 116.4 Mg Wireless Ultra-Lightweight Microstimulator for Cyborg Bees

A Sub-100 mg Electromagnetically Driven Insect-inspired Flapping-wing Micro Robot Capable of Liftoff and Control Torques Modulation

Design of the first sub-milligram flapping wing aerial vehicle

RIS-aided Wireless Power Transfer for Unmanned Aerial Vehicles

Design and Analysis of an Untethered Micro Flapping Robot Which Can Glide on the Water

One-wing polymer micromachined transmission for insect-inspired flapping wing nano air vehicles

Controlled flight of a self-powered micro blimp driven by insect-sized flapping-wing thrusters

FireFly: An Insect-Scale Aerial Robot Powered by Electroluminescent Soft Artificial Muscles

Evaluation of RF Wireless Power Transfer for Low-Power Aircraft Sensors

A High-Efficiency Wireless Power Transfer System for Unmanned Aerial Vehicle Considering Carbon Fiber Body

A Meter-scale Ornithopter Capable of Jumping Take-off

A wearable wireless platform for visually stimulating small flying insects

Nanogenerators Integrated Self-Powered Multi-Functional Wings for Biomimetic Micro Flying Robots

Experimental Energy Consumption Analysis of a Flapping-Wing Robot