Abstract:Slightly acidic electrolyzed water (SAEW) with pH 5.0-6.5 is produced by electrolysis of dilute hydrochloric acid or salt solution in a chamber without a membrane. SAEW can effectively kill various pathogenic bacteria as one of the most potential green disinfectants. However, SAEW is susceptible to being exposed to time, air, and illumination etc. The influence of SAEW for inactivation ofEscherichia coli on white shrimp (Litopenaeus vannamei) under different washing conditions was investigated. At room temperature, the effectiveness of SAEW (with available chlorine concentration (ACC) of 20 mg/L, pH value of 6.1 and ORP of 812 mV) to inactivate Escherichia coli with different dipping times (2, 5 and 10 min), weight ratio of shrimp to SAEW (1:4, 1:10 and 1:20) was evaluated, and changes of ACC were also measured. For inoculation, each shrimp was determined to be intact, and then exposed to a 90°C water bath boiling for 20 min. to inactivate bacteria on the surface of shrimps. Each sample was inoculated with E. coli by spreading 0.5 mL onto each surface respectively and then placed in a clean bench for 20 min. to allow for the attached E. coli. The level of E. coli on the shrimp surface was ensured to be of approximately 6.0-7.0 lgCFU/mL, and bacterial cells on surfaces of shrimp or in residual solution after treatment were counted using a dilution plate count at 37°C for 24h onto nutrient agar, and shrimp that were not washed were used as a control. Moreover, the decay kinetics models of ACC in SAEW during disinfection were established. The effect of SAEW on meat quality was also evaluated, respectively from color, pH value, hardness, and the moisture distribution. The results showed that SAEW has a strong bactericidal activity againstE coli. on white shrimp, while distilled water has a relative weaker role. As the action time prolonged, and the amount of SAEW increased, the bactericidal effect of SAEW was intensified. Meanwhile, the residue bacteria colony in SAEW was also reduced and expenses of active chlorine was increased as the action time was prolonged, and the amount of SAEW increased during the disinfection process. The effective order of time on the bactericidal activity of SAEW was 10 min > 5 min > 2 min under the same ratio of shrimp to SAEW, dipping in SAEW (weight ratio of shrimp to SAEW was 1:4) for 10 min reducedE. coli population from 6.6 to 3.9 lgCFU/mL, which better than the control treatment. E.coli counts in a residual solution can reduce by 1-2 lgCFU/mL. Increasing the amount of SAEW enhanced the bactericidal effect obviously. The decay of ACC and bactericidal kinetic followed first-order kinetics during the disinfection process, and the model had good predicted results. In addition, there was no significant differences between the treated meat quality by SAEW and the controls, respectively from color, pH, hardness, and the moisture distribution of white shrimp meat. Therefore, SAEW has a strong bactericidal activity, and does not affect the meat quality of white shrimp, and has a great potential for application compared with the traditional thermal treatment.

Effect of shell disinfection with AQUALYTE (NEUTRAL ANOLYTE) on inactivation of Salmonella enteritidis and quality of edible eggs

Effect of combined electrolyzed reduced water and slightly acidic electrolyzed water spraying on the control of Salmonella, eggshell quality, and shelf life of eggs during storage

Trans-cinnamaldehyde nanoemulsion wash inactivates Salmonella Enteritidis on shelled eggs without affecting egg color

Disinfection effect and kinetics of slightly acidic electrolyzed water for white shrimp

Some topical issues of prevention of salmonella infection in the production and consumption of chicken eggs: the role of disinfection in the context of antiepidemic measures

A Successful Technique for the Surface Decontamination of Salmonella enterica Serovar Typhimurium Externally Contaminated Whole Shell Eggs Using Common Commercial Kitchen Equipment

Synergy of Biodegradable Polymer Coatings with Quaternary Ammonium Salts Mediating Barrier Function Against Bacterial Contamination and Dehydration of Eggs

Efficacy of pectin-based caproic acid, caprylic acid, linalool, and cuminaldehyde coatings in reducing Salmonella Heidelberg on chicken eggs

Cold atmospheric pressure air plasma jet disinfection of table eggs: Inactivation of Salmonella enterica, cuticle integrity and egg quality

Review of food grade disinfectants that are permitted for use in egg packing centres

Recovery of Salmonella and Escherichia coli from commercial egg shells and effect of translucency on bacterial penetration in eggs

Heating Rate during Shell Egg Thermal Treatment Elicits Stress Responses and Alters Virulence of Salmonella enterica Serovar Enteritidis; Implications for Shell Egg Pasteurization

Single and combined effects of oregano leaf and clove oils on the reduction of salmonella enteritidis on chicken egg shells

Atmospheric pressure plasma jet treatment of Salmonella Enteritidis inoculated eggshells

Sustainable Bacterial Control of Hatching Eggshells Using Essential Oils

Survey of shell egg processing plant sanitation programs: effects on non-egg-contact surfaces

HIGHLIGHT ON THE INFLUENCE OF LACTIC ACID AND OZONIZED WATER ON THE SHELF LIFE OF CHICKEN FILLET

Hot air treatment for surface decontamination of table eggs experimentally infected with Salmonella, Listeria, and Escherichia coli

Beneficial effect of probiotics supplementation on quality of edible fresh table eggs during storage

Hatching Egg Sanitizers Based on Essential Oils: Microbiological Parameters, Hatchability, and Poultry Health

Effect of Sodium Selenite, Selenium Yeast, and Bacterial Enriched Protein on Chicken Egg Yolk Color, Antioxidant Profiles, and Oxidative Stability