Abstract:During the tunneling process of earth pressure balance (EPB) shield machines, the undrained compressibility of foam-conditioned soils in the excavation chamber is essential for reducing the fluctuation of chamber pressure and guaranteeing effective tunnel face support. As conditioned soil is simplified to be radially constrained by the shield shell and in a quasi-one-dimensional compression state under the face pressure along the tunneling direction, a mechanism-inspired analytical model was developed to estimate the void ratio and pore pressure of foam-conditioned coarse-grained soils (FCS) in one-dimensional compression based on effective stress analysis. In the model, an expansion coefficient was proposed to characterize the filling state of foam bubbles in pores and a void ratio threshold (eth) was defined as the transition point of the FCS with and without effective stress. The variation of void ratio and pore pressure with total stress of FCS in two distinct stages of the void ratio (e), either greater or smaller than its threshold, were calculated based on Boyle’s law and the hyperbolic assumption of the effective stress–strain relation of soil. A good agreement between the analytical and experimental results verified the reliability of the proposed analytical method. Furthermore, a parametric study indicated that the compressibility increases with an increase in the expansion coefficient and foam injection ratio (FIR). Increasing additional water content leads to a decrease in compressibility under low pressure (σv ≤ 20 kPa), but an increase in compressibility under high pressure (σv > 20 kPa). Meanwhile, the pore pressure in FCS in the stage of e < eth also positively correlates with the expansion coefficient, FIR, and additional water content. The research findings would provide a convenient method to estimate the undrained compressibility behavior of FCS and theoretically guide the soil conditioning optimization in EPB tunneling.

The φ = 0 Concept: Review of its Theoretical Basis and Pragmatic Issues with Implementation

A Method for Determining Critical Thickness of Base Soil of Foundation Pit Subjected to Confined Water

Initial Excess Pore Water Pressures Induced by Tunnelling in Soft Ground

Theoretical Breakage Mechanics and Experimental Assessment of Stresses Surrounding Piles Penetrating into Dense Silica Sand

On the Dissipation of Negative Excess Porewater Pressure Induced by Excavation in Soft Soil

Limit equilibrium analysis of anisotropic soft clay stability against excavation basal heave

Experimental Study on Shear Strength Considering Initial Void Ratio and Plasticity Index

Analysis of 1d Consolidation with Non-Darcian Flow Described by Exponent and Threshold Gradient

Revisiting the Fundamental Concepts of Soil Mechanics Using the General Effective Stress Concept for Saturated Geomaterials

Effect of Initial Pore Pressure on Undrained Shear Behaviour of Fine-Grained Gassy Soil

Numerical Analysis Of Unsaturated Excavation By Using Suction Stress

Initiation and Failure Mechanism of Base Instability of Excavations in Clay Triggered by Hydraulic Uplift

Myths and misconceptions related to unsaturated soil mechanics

Quasi-static analysis for quantitative estimation of improvement effect of cohesionless soil treated by dynamic compaction

An Analytical Framework for Assessing the Unsaturated Bearing Capacity of Strip Footings under Transient Infiltration

Initial Hypotheses for Modeling and Numerical Analysis of Rockfill and Earth Dams and Their Effects on the Results of the Analysis

Undrained Stability of Unsupported Rectangular Excavations: Anisotropy and Non-Homogeneity in 3D

Water Pressure Effects on Strength and Deformability of Fractured Rocks Under Low Confining Pressures

Estimating normal effective stress degradation in sand under undrained simple shear condition

Physical Interpretation of Shear-Rate Behaviour of Soils and Geotechnical Solution to the Coefficient of Start-Up Friction with Low Inertial Number.

A Unified Analytical Model for Undrained Compressibility Behavior of Foam-Conditioned Coarse-Grained Soils Based on Effective Stress Analysis