Abstract:In the frame of the RETALT (RETro propulsion Assisted Landing Technologies) project, the aerodynamics of reusable launch vehicles reentering the atmosphere and descending and landing with the aid of retro propulsion are studied. In particular, series of wind tunnel tests are performed to assess the aerodynamic properties of such a vehicle in the various flight phases from hypersonic and supersonic re-entry down to subsonic conditions at touch down. This paper discusses the results of wind tunnel tests in the Hypersonic Wind Tunnel Cologne (H2K) at the Supersonic and Hypersonic Flow Technologies Department of the German Aerospace Center (DLR) in Cologne for the hypersonic retro propulsion maneuver during the re-entry burn. Mach numbers of 5.3 and 7.0 were tested with a variation of thrust coefficient, Reynolds number, angle of attack, cold and heated air. A single-engine configuration and a configuration with three active engines were tested. In all tests, the engine exhaust was simulated using ambient temperature or heated air. Dependencies of the flow features of the square root of the thrust coefficient known from literature for the single-engine case can be confirmed and extended to the three-engine configuration. For the single-engine case, the formation of vortex rings was observed, which eventually leads to strong individual vortices and extensive flow field disturbances. The heating of the supply air up to 600 K mitigates condensation in the retro plume, while the overall flow structures remained unchanged. High thrust coefficients generally lead to vanishing pressure coefficients on the engine bay. The single and the three-engine cases are comparable in this sense. The Mach number and Reynolds number are of subordinate importance for the pressures on the vehicle, while the thrust coefficient is the dominating similarity parameter. Pressure coefficients far downstream of the retro plume are affected less and, therefore, are not negligible at non-zero angles of attack. In this paper, the methodology of the wind tunnel tests and the results obtained are described in detail.

Test and Evaluation of Next Generation 65-foot, High-Reach Extendable Turret (HRET)

Investigating the Potential of Parallel Hybrid-Electric Retrofit of Narrow-Body Airliner for Emission Reduction

Specific Technologies of Aviation Rescue and Firefighting Operations over the Years

Hydrogen Jet Fire from a Thermally Activated Pressure Relief Device (TPRD) from Onboard Storage in a Naturally Ventilated Covered Car Park

Quantitative Fit Evaluation of Three Potential Inflight Fire Fighting Respiratory Protection Systems

Respiratory protection for firefighters--Evaluation of CBRN canisters for use during overhaul II: In mask analyte sampling with integrated dynamic breathing machine

Crashworthiness of a Composite Bladder Fuel Tank for a Tilt Rotor Aircraft

Planning and Evaluation of Water-Dropping Strategy for Fixed-Wing Fire Extinguisher Based on Multi-Resolution Modeling

Investigation of External Fuel Fire Hazards of Full-Scale Aircraft Fuselage under Sub-Atmospheric Pressure

Analysis of Fire Water Monitor Jet Reaction Forces and Their Influences on the Roll Stabilities of Urban Firefighting Vehicle

Conceptual Design of a Hydrogen-Hybrid Dual-Fuel Regional Aircraft Retrofit

Tethered UAV with Combined Multi-rotor and Water Jet Propulsion for Forest Fire Fighting

Hypersonic retro propulsion for reusable launch vehicles tested in the H2K wind tunnel

Numerical and Experimental UAV Structure Investigation by Pre-Flight Load Test

Analyzing the future of army aeromedical evacuation units and equipment: a mixed methods, requirements-based approach

Wind tunnel experiments of interstage segments used for aerodynamic control of retro-propulsion assisted landing vehicles

Aerothermal databases and load predictions for Retro Propulsion-Assisted Launch Vehicles (RETALT)

High-Fidelity Simulation Training for Helicopter Emergency Medical Services Flight Nurses: A Report From the First Italian Experience

Quantitative Risk Assessment Methodology for Hydrogen Tank Rupture in a Tunnel Fire

Design and Analysis of All-Terrain Differential-Driven Caterpillar-Wheeled Based Unmanned Fire Extinguisher Robot

An Evaluation of the Firefighting Performance of Alcohol-Resistant Aqueous Film Forming Foams (AFFF-AR) and Alcohol-Resistant Fluorine-Free Foams (FFF-AR) in the Past Two Decades