Abstract:Chronic implantation of intracortical microelectrode arrays (MEAs) capable of recording from individual neurons can be used for the development of brain-machine interfaces. However, these devices show reduced recording capabilities under chronic conditions due, at least in part, to the brain's foreign body response (FBR). This creates a need for MEAs that can minimize the FBR to possibly enable long-term recording. A potential approach to reduce the FBR is the use of MEAs with reduced cross-sectional geometries. Here, we fabricated 4-shank amorphous silicon carbide (a-SiC) MEAs and implanted them into the motor cortex of seven female Sprague-Dawley rats. Each a-SiC MEA shank was 8 μm thick by 20 μm wide and had sixteen sputtered iridium oxide film (SIROF) electrodes (4 per shank). A-SiC was chosen as the fabrication base for its high chemical stability, good electrical insulation properties, and amenability to thin film fabrication. Electrochemical analysis and neural recordings were performed weekly for 4 months. MEAs were characterized pre-implantation in buffered saline and in vivo using electrochemical impedance spectroscopy and cyclic voltammetry at 50 mV/s and 50,000 mV/s. Neural recordings were analyzed for single unit activity. At the end of the study, animals were sacrificed for immunohistochemical analysis. We observed statistically significant, but small, increases in 1 and 30 kHz impedance values and 50,000 mV/s charge storage capacity over the 16-week implantation period. Slow sweep 50 mV/s CV and 1 Hz impedance did not significantly change over time. Impedance values increased from 11.6 MΩ to 13.5 MΩ at 1 Hz, 1.2 MΩ-2.9 MΩ at 1 kHz, and 0.11 MΩ-0.13 MΩ at 30 kHz over 16 weeks. The median charge storage capacity of the implanted electrodes at 50 mV/s was 58.1 mC/cm2 on week 1 and 55.9 mC/cm2 on week 16, and at 50,000 mV/s, 4.27 mC/cm2 on week 1 and 5.93 mC/cm2 on week 16. Devices were able to record neural activity from 92% of all active channels at the beginning of the study, At the study endpoint, a-SiC devices were still recording single-unit activity on 51% of electrochemically active electrode channels. In addition, we observed that the signal-to-noise ratio experienced a small decline of -0.19 per week. We also classified observed units as fast and slow repolarizing based on the trough-to-peak time. Although the overall presence of single units declined, fast and slow repolarizing units declined at a similar rate. At recording electrode depth, immunohistochemistry showed minimal tissue response to the a-SiC devices, as indicated by statistically insignificant differences in activated glial cell response between implanted brains slices and contralateral sham slices at 150 μm away from the implant location, as evidenced by GFAP staining. NeuN staining revealed the presence of neuronal cell bodies close to the implantation site, again statistically not different from a contralateral sham slice. These results warrant further investigation of a-SiC MEAs for future long-term implantation neural recording studies.

A Minimally Invasive Endovascular Stent-Electrode Array for Chronic Recordings of Cortical Neural Activity

Minimally invasive endovascular stent-electrode array for high-fidelity, chronic recordings of cortical neural activity

Making a case for endovascular approaches for neural recording and stimulation

A systematic review of endovascular stent-electrode arrays, a minimally invasive approach to brain-machine interfaces.

Endocisternal interfaces for minimally invasive neural stimulation and recording of the brain and spinal cord

Venous Sinus Stent to Treat Paralysis

Closed-loop interaction with the cerebral cortex: a review of wireless implant technology

A Multi-Electrode Array Coupled with Fiberoptic for Deep-Brain Optical Neuromodulation and Electrical Recording.

Distribution of Electrical Stimulation Current of a Minimally Invasive Endovascular Stent-Electrode

A flexible implantable microelectrode array for recording electrocorticography signals from rodents

In vivo evaluation of a μECoG array for chronic stimulation

Chronic subdural electrocorticography in nonhuman primates by an implantable wireless device for brain-machine interfaces

Stable, chronic in-vivo recordings from a fully wireless subdural-contained 65,536-electrode brain-computer interface device

Ultraflexible endovascular probes for brain recording through micrometer-scale vasculature

A Multi-Channel, Flex-Rigid ECoG Microelectrode Array for Visual Cortical Interfacing

Planar amorphous silicon carbide microelectrode arrays for chronic recording in rat motor cortex

Revolutionizing Intrusive Neural Interfaces: Vascular Stent-Based Neural Electrodes

Intravascular Neural Interface with Nanowire Electrode.

Flexible, scalable, high channel count stereo-electrode for recording in the human brain

Shape-changing electrode array for minimally invasive large-scale intracranial brain activity mapping

Recent advancement of electrocorticography (ECoG) electrodes for chronic neural recording/stimulation