Abstract:Chronic implantation of intracortical microelectrode arrays (MEAs) capable of recording from individual neurons can be used for the development of brain-machine interfaces. However, these devices show reduced recording capabilities under chronic conditions due, at least in part, to the brain's foreign body response (FBR). This creates a need for MEAs that can minimize the FBR to possibly enable long-term recording. A potential approach to reduce the FBR is the use of MEAs with reduced cross-sectional geometries. Here, we fabricated 4-shank amorphous silicon carbide (a-SiC) MEAs and implanted them into the motor cortex of seven female Sprague-Dawley rats. Each a-SiC MEA shank was 8 μm thick by 20 μm wide and had sixteen sputtered iridium oxide film (SIROF) electrodes (4 per shank). A-SiC was chosen as the fabrication base for its high chemical stability, good electrical insulation properties, and amenability to thin film fabrication. Electrochemical analysis and neural recordings were performed weekly for 4 months. MEAs were characterized pre-implantation in buffered saline and in vivo using electrochemical impedance spectroscopy and cyclic voltammetry at 50 mV/s and 50,000 mV/s. Neural recordings were analyzed for single unit activity. At the end of the study, animals were sacrificed for immunohistochemical analysis. We observed statistically significant, but small, increases in 1 and 30 kHz impedance values and 50,000 mV/s charge storage capacity over the 16-week implantation period. Slow sweep 50 mV/s CV and 1 Hz impedance did not significantly change over time. Impedance values increased from 11.6 MΩ to 13.5 MΩ at 1 Hz, 1.2 MΩ-2.9 MΩ at 1 kHz, and 0.11 MΩ-0.13 MΩ at 30 kHz over 16 weeks. The median charge storage capacity of the implanted electrodes at 50 mV/s was 58.1 mC/cm2 on week 1 and 55.9 mC/cm2 on week 16, and at 50,000 mV/s, 4.27 mC/cm2 on week 1 and 5.93 mC/cm2 on week 16. Devices were able to record neural activity from 92% of all active channels at the beginning of the study, At the study endpoint, a-SiC devices were still recording single-unit activity on 51% of electrochemically active electrode channels. In addition, we observed that the signal-to-noise ratio experienced a small decline of -0.19 per week. We also classified observed units as fast and slow repolarizing based on the trough-to-peak time. Although the overall presence of single units declined, fast and slow repolarizing units declined at a similar rate. At recording electrode depth, immunohistochemistry showed minimal tissue response to the a-SiC devices, as indicated by statistically insignificant differences in activated glial cell response between implanted brains slices and contralateral sham slices at 150 μm away from the implant location, as evidenced by GFAP staining. NeuN staining revealed the presence of neuronal cell bodies close to the implantation site, again statistically not different from a contralateral sham slice. These results warrant further investigation of a-SiC MEAs for future long-term implantation neural recording studies.

Planar amorphous silicon carbide microelectrode arrays for chronic recording in rat motor cortex

Amorphous silicon carbide ultramicroelectrode arrays for neural stimulation and recording

Chronic in vivo stability assessment of carbon fiber microelectrode arrays

A Silicon Based Implantable Microelectrode Array for Electrophysiological and Dopamine Recording from Cortex to Striatum in the Non-Human Primate Brain.

Flexible Silk Fibroin-Based Microelectrode Arrays for High-Resolution Neural Recording

Long-term stability of neural signals from microwire arrays implanted in common marmoset motor cortex and striatum

Chronic subdural electrocorticography in nonhuman primates by an implantable wireless device for brain-machine interfaces

Structural and functional changes of deep layer pyramidal neurons surrounding microelectrode arrays implanted in rat motor cortex

Ultra-small carbon fiber electrode recording site optimization and improved in vivo chronic recording yield

A flexible implantable microelectrode array for recording electrocorticography signals from rodents

Fully Integrated 3D Microelectrode Arrays with Polydopamine-Mediated Silicon Dioxide Insulation for Electrophysiological Interrogation of a Novel 3D Human, Neural Microphysiological Construct.

Silicon-based Microelectrode Arrays for Stimulation and Signal Recording of in Vitro Cultured Neurons

Design and fabrication of a microelectrode array for studying epileptiform discharges from rodents

Fabrication of a Monolithic Implantable Neural Interface from Cubic Silicon Carbide

A Multimodal, SU-8 - Platinum - Polyimide Microelectrode Array for Chronic In Vivo Neurophysiology

Chronic neural interfacing with cerebral cortex using single-walled carbon nanotube-polymer grids

A silicon-based microelectrode array with a microdrive for monitoring brainstem regions of freely moving rats

Evaluation of chronically implanted subdural boron doped diamond/CNT recording electrodes in miniature swine brain

Wafer-Scale Fabrication and Assembly Method of Multichannel Microelectrode Arrays for ECoG Application

Stable, long-term single-neuronal recording from the rat spinal cord with flexible carbon nanotube fiber electrodes

Implantable Subdural Electrode Arrays for Neural Recordings Based on MEMS Technologies